2012 Audi Q7 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
What could happen: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
The fix: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 18V818000 (manufacturer code 20BJ).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-253-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
Consequence: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
What could happen: A fuel leak in the presence of an ignition source increases the risk of a fire.
The fix: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 16V660000 (manufacturer code 20W9).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-253-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. In the affected vehicles the fuel injection system may experience a fuel leak.
What could happen: A fuel leak in the injection system in the presence of an ignition source, increases the risk of a fire.
The fix: Volkswagen will notify owners, and dealers will replace the fuel rails and corresponding seals, free of charge. The recall began on March 17, 2015. Owners may contact Audi customer service at 1-800-822-2834 or Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 24AP for Audi custo…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 15V019000 (manufacturer code 24AP for Audi customers and 24BK for Volkswagen customers).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-822-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
Summary: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2012 Audi S4, S5, Q7, 2012 Audi A6, Volkswagen Touareg Hybrid, and 2012-2013 Audi A7 vehicles. In the affected vehicles the fuel injection system may experience a fuel leak.
Consequence: A fuel leak in the injection system in the presence of an ignition source, increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel rails and corresponding seals, free of charge. The recall began on March 17, 2015. Owners may contact Audi customer service at 1-800-822-2834 or Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 24AP for Audi customers and 24BK for Volkswagen customers.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."
What could happen: An overloaded vehicle can increase the risk of a crash.
The fix: Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 23V086000 (manufacturer code 50G5).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-253-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: Volkswagen Group of America, Inc. (Audi) is recalling certain 2009-2015 Q7 vehicles. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."
Consequence: An overloaded vehicle can increase the risk of a crash.
Remedy: Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2012 Audi Q7 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (12), Engine (8), Steering (4), Visibility (wipers / glass) (4), Unknown Or Other (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
01/18/2026 · Steering
On or December 5th, 2025 (4 days after taking possession of the vehicle, I experienced a sudden and severe steering system failure while driving. When turning the steering wheel (even slightly), the vehicle produced a loud buzzing/grinding noise and the steering effort increased significantly, creating an immediate safety hazard. Because the steering issue…
03/04/2025 · Fuel system
The contact owns a 2012 Audi Q7. The contact stated that upon starting the vehicle, there was an abnormal odor inside the vehicle with the check engine warning light illuminated. The vehicle was taken to a local dealer to be diagnosed. The contact was informed that the high-pressure fuel pump and the fuel system were faulty and needed to be replaced. The ve…
03/04/2025 · Engine
There have been continuous indicators by way of the check engine light repeatedly appearing on my vehicle's dash for a number of years. A different determination was always discovered each time I took my vehicle to the only Audi Certified Dealership in my area. Most recently, I have been told that my vehicle now requires a Fuel System Replacement, High P…
01/24/2025 · Unknown Or Other
On November 2, 2015, the Environmental Protection Agency and California Air Resources Board informed Volkswagen Group companies that my Model Year 2012 3.0L Turbo Diesel Injection (TDI) vehicle did not comply with Federal and California emissions standards. In the approved emissions modification, Audi Lynbrook claims to have removed the software that reduce…
02/20/2024 · Unknown Or Other
Since I bought my vehicle it has been burning oil I am adding oil every two to three days because it burns it and the smells burnt and the light comes on I have to add 3 oil bottles every two to three days It smells burnt and I cannot drive for long periods of times because I am scared something can happen. I have a 2012 audi q7.
02/19/2021 · Lights · crash
HELLO! I HAVE AN 2012 AUDI Q7 AND MY AIRBAGS NEVER DEPLOYED AT 50 MPH IMPACT. IT'S A TOTAL LOSS. DO I HAVE GROUNDS FOR A LAWSUIT?
10/15/2020 · Engine
VEHICLE HAS NOT EVEN REACH 92K MILES AND THE WATERPUMP IS A ALREADY FAILING. AUDI THIS IS A KNOW ISSUE BUT THE REMEDY HAS NOT BEEN FIXED. THEY ONLY WAY TO FIX THIS IS TO REPLACE WITH NEW UNIT. I UNDERSTAND AUDI SPECIFICALLY MADE A "WEEP" HOLE TO WARN THE OWNER BEFORE THE WHOLE UNIT FAILS. THIS CAUSES COOLANT TO LEAK WHICH EVENTUALLY GIVES YOU THE LOW COOLAN…
10/14/2020 · Fuel system
2012 AUDI Q7 3.0T S LINE PRESTIGE, 91K MILES! STARTED AS SMALL GASOLINE SMELL BECOMING STRONGER THROUGHOUT THE NEXT COUPLE DAYS. SMELLED REALLY STRONG AROUND REAR LEFT DOOR AREA AND INSIDE CABIN. INVESTIGATED FUEL LEAK AND NOTICE UNDERNEATH THE SUV, FUEL DRIPPING DOWN THE SIDE OF ONE OF THE TWO FUEL TANKS. DISCONNECT BATTERY, REMOVE REAR SEAT TO ACCESS FUEL…