1996 BMW 318ti recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE…
What could happen: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 318TI.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V131000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Visibility (wipers / glass) (3), Electrical system (2), Equipment (1), Vehicle Speed Control (1), Airbags (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/08/2010 · Visibility (wipers / glass)
THIS IS THE 8TH TIME PASSENGER SIDE WINDOW OF MY 1996 BMW318TI IS IN NEED OF REPAIR. MOTOR REPLACED ONCE, THAN REGULATOR, FOLLOWED BY NUMEROUS REPAIRS FOR SLIDES OR CLIPS TO BE FIXED. WHEN PUTTING UP WINDOW THERE IS A LOUD CRACK AND THE WINDOW GOES OFF TRACK, SO IT CAN NEITHER GO UP OR DOWN. THIS IS A COSTLY COMPLAINT FROM MANY OWNERS OF THIS CAR SO THERE H…
06/07/2009 · Visibility (wipers / glass)
MY 1996 BMW 318TI - DRIVER SIDE FRONT WINDOW HAS 3 TIMES IN LAST 5 YEARS FALLEN INTO THE DOOR INTERIOR WHILE DRIVING. I HAVE HAD THIS REPAIRED NOW 3 TIMES IN 5 YEARS AT A TOTAL COST TO BE OF $1300. THIS IS A SYSTEMIC DESIGN AND SAFETY PROBLEM THAT OCCURS NOT MOST OF THE 3 SERIES BMW FROM 1995 TO 2002. BMW UTILIZES A VERY POOR CHANNEL DESIGN TO RE…
07/10/2006 · Visibility (wipers / glass)
THE WINDOWS FALL OFF TRACK ON MY 1996 BMW E36 318TI. THIS HAS BEEN HAPPENING TO BOTH WINDOWS ON MY CAR REGULARLY FOR THE PAST 2.5 YEARS I HAVE OWNED THE CAR AND HAS RUINED THE TINT ON BOTH WINDOWS. I HAVE SPOKEN WITH OTHER 318TI OWNERS ABOUT THIS PROBLEM AND HAVE FOUND THAT THIS A HIGHLY COMMON FAILURE AND NORMALLY COSTS SEVERAL HUNDRED DOLLARS TO REPAIR,…
06/02/2006 · Vehicle Speed Control
I AM AN ENGINEER WHO PERFORMS FAILURE ANALYSIS - MY OBSERVATIONS ARE BASED ON SIGNIFICANT EXPERIENCE IN THIS FIELD. THE CAR IS A 1996 BMW 318TI WITH A 5 SPD MANUAL TRANSMISSION. THE ENGINE IS STOCK. I WAS DRIVING MY 318TI ON THE INTERSTATE HIGHWAY AND NOTICED THAT THE SPEED WAS INCREASING WITHOUT THROTTLE INPUT. I TURNED THE CRUISE CONTROL OFF THINKING…
08/29/2003 · Electrical system
WHEN TAKING THE KEY OUT OFIGNITION VEHICLE CONTINUED TO RUN. *AK
12/06/2002 · Electrical system
IGNITION SWITCH FAILURE. WHEN ATTEMPTING TO TURN OFF CAR, KEY MOVED TO OFF POSITION WITHOUT RESISTANCE BUT DID NOT TURN OFF CAR. SWITCH LOCKED IN OFF POSITION BUT KEY WOULD MOVE AND CAR CONTINUED TO RUN. KEY COULD BE REMOVED AND REINSERTED BUT COULD NOT TURN OFF CAR. HAD TO PULL FUSE ON THE FUEL INJECTION SYSTEM TO STALL ENGINE AND DISCONNECT BATTERY TO…
10/27/1997 · Airbags · crash
WHILE DRIVING 30 MPH VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AND THE AIRBAGS DID NOT DEPLOY. OWNER WILL CONTACT THE MANUFACTURER. *AK
10/27/1997 · Body / structure
STRIP ON DOOR PEELING MAKING IT HARD FOR DRIVER TO CLOSE THE DOOR.