1994 BMW 325is recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE…
What could happen: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 325IS.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V131000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
What could happen: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 325IS.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 96V111000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Notes: SYSTEM: BRAKES; HYDRAULIC; SWITCH; BRAKE LIGHT. VEHICLE DESCRIPTION: PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 5, 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
What could happen: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
The fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 325IS.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 98V178000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Notes: OWNER NOTIFICATION BEGAN MARCH 31, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (2), Electrical system (2), Airbags (2), Body / structure (1), Suspension (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/05/2017 · Body / structure
OUTSIDE DOOR HANDLES ON BOTH DOORS BECAME INOPERABLEWITHIN A MONTH OF EACH OTHER ALSO TRUNK LATCH BROKE DUE TO THE WAY IT IS ATTATCHED TO TRUNK LID IE TWO SCREWS THRU SHEET METAL, SHEET METAL BROKE AROUND BOTH SCREWS
08/30/2011 · Transmission / drivetrain
OWNER OF A 1994 325IS. WAS DRIVING ON HIGHWAY AND TRANSMISSION SUDDENLY DIED DOWN (SLIPPED OUT OF GEAR) ALMOST CAUSING THE VEHICLES BEHIND TO ALMOST CRASH INTO ME. IN ILLINOIS. CALLED THE NATIONAL BMW CUSTOMER CENTER AND THEY SAY THEY HAVE NO ACTIVE RECALL DESPITE NUMEROUS COMPLAINT OF INCIDENTS WITH THE TRANSMISSION OF 325 I IN THE CONSUMER REPORTS SITE…
05/06/2005 · Suspension · crash
I AM A MEMBER OF THE BMWCCA AND A BMW AUTOMTIVE ENTHUSIAST. I HAVE NOTICE FOR MANY YEARS THE OCCURANNCE OF A COMMON FAILURE IN E36 AND E46 BODY STYLES - FOR ALL YEARS OF PRODUCTION. THE REAR SUBFRAME IS ATTACHED AT FOUR MOUNTING LOCATIONS TO THE UNIBODY. THE UNIBODY IS NOT REINFORCED AT THE ATTACHMENT POINTS. FAILURES HAVE OCCURED WHERE THE UNIBODY SHEE…
09/27/2004 · Latches / locks
LTR RE A DEFECTIVE HOOD LATCH ON A 1994 BMW 325IS, REQUESTING A DEFECT INVESTIGATION. WHILE DRIVING, THE HOOD LATCH DISENGAGED AND CAUSE THE HOOD TO OPEN. *JB
08/06/2001 · Engine
AFTER TAKING VEHICLE THROUGH A CARWASH ENGINE HYDROLOCKED AND CAUSED FUEL TO INJECT INTO ENGINE. DEALER SAID ENGINE HAS TO BE REPLACED.*AK CONSUMER STATES DME SHORTED OUT CAUSING IT TO HYDROLOCK AND CAUSING ENGINE AND FUEL COMPONENTS TO BE DAMAGED INTERNALLY. *SLC
07/11/2000 · Visibility (wipers / glass)
WHILE DRIVING ENGINE OVERHEATED. VEHICLE HAD TO BE TOWED TO DEALER, AND TECHNICIAN TOLD CONSUMER THAT WAS CAUSED BY THE HEATING CORE.*AK
10/27/1999 · Airbags
WHEN THE VEHICLE IS STARTED, AIRBAG LIGHT COMES ON AND WILL NOT GO OFF. DEALER HAS NOT SEEN VEHICLE. *AK
10/15/1999 · Transmission / drivetrain
THE 1994 BMW 3 SERIES HAS A CLUTCH LINING PROBLEM THAT WILL CAUSE THE CAR TO BUCK AND THROW ITSELF FORWARD WHEN STUCK IN STOP AND GO TRAFFIC FOR ANY AMOUNT OF TIME. ALTHOUGH THIS IS CALLED A MINOR INCOMVENIENCE BY BMW, IT CAN CAUSE A LOW IMPACT ACCIDENT IF THE CLUTCH AND DUAL MASS FLY WHEEL ARE NOT REPLACED.... $2000 LATER.