2009 BMW F 800 Gs Us recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Wheels / tires (5), Fuel system (3), Gasoline (3), Suspension (3), Engine (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
05/04/2010 · Wheels / tires
FAILURE OF CHAIN AND REAR WHEEL BEARING AT 7139 MILES ON A 8 MONTH OLD BMW F800GS. BIKE WAS TAKEN INTO BMW DEALER FOR NEW CHAIN AS OLD CHAIN WAS LOSING 'O' RINGS REAR WHEEL WAS REMOVED AND AT MY REQUEST BEARINGS CHECKED AS I HAD HEARD OF FAILURES ON FROM THE INTERNET. REAR BEARING WAS FOUND TO BE HIGHLY WORN AND 'GRITTY' FEELING. DEALER REPLACED BEARING UND…
03/01/2010 · Fuel system
FUEL TANK ON NEW (600 MILES) BMW F800GS MOTORCYCLE HAS DEVELOPED A SIX (6") CRACK. SEPARATION IS APPROX 1/16". RETURNED MOTORCYCLE TO DEALER WHERE PURCHASED AND ISSUE HAS NOT BEEN RECTIFIED. *TR
03/01/2010 · Fuel system
NOTICED A CRACK ON THE SIDE OF THE GAS TANK. THE GAS TANK IS SPLIT OPEN. THIS SEEMS TO GREATLY INCREASE THE RISK OF EXPLOSION DUE TO GAS FUMES IF ANY HEAT SOURCE/SPARK MADE GETS CLOSE. *TR
12/28/2009 · Fuel system
GAS TANKS HAS CRACKS ON BOTH SIDES. *TR
12/22/2009 · Wheels / tires
REAR WHEEL BEARING FAILED AT 6000 MILES. THIS COULD HAVE LED TO CATASTROPHIC INJURY HAD I NOT FOUND THE PROBLEM DURING ROUTINE MAINTENANCE. CHECKING THE WHEEL BEARING IS NOT ROUTINE AT 6000 MILES. *TR
10/28/2009 · Wheels / tires
AFTER READING ABOUT SEVERAL FAILURES OF REAR WHEEL BEARINGS ON F800GS MOTORCYCLES I CHOSE TO INSPECT THE REAR WHEEL BEARINGS ON MY 2009 BMW F800GS MOTORCYCLE. I DISCOVERED THEM TO BE WORN AND ROUGH FEELING WITH EVIDENCE OF SERIOUS BRINNELING. THE MOTORCYCLE HAS 8800 MILES. UPON DISASSEMBLY I FOUND THE FIT BETWEEN THE WHEEL BORE AND THE BEARING ON THE DISC…
10/27/2009 · Wheels / tires
M / Y 2009 BMW F800GS MOTORCYCLE, BUILD DATE 10/08. REAR WHEEL BEARING FAILURE NOTED DURING ROUTINE MAINTENANCE AT APPROXIMATELY 5,500 MILES. CATASTROPHIC FAILURE COULD RESULT IN REAR TIRE LOCKING UP, CAUSING SEVERE INJURY OR DEATH. BMW DEALER IS REPLACING PARTS UNDER WARRANTY. *TR
10/23/2009 · Suspension
I HAVE A 2009 BMW F800GS. I READ ABOUT CATASTROPHIC BEARING FAILURES HAPPENING ON OTHER F800GS REAR WHEELS AND CHECKED MY BEARING BY HAND WHEN I HAD THE REAR WHEEL OFF AT 8000 MILES FOR TIRE REPLACEMENT. THE BEARING ON THE ROTOR SIDE OF THE WHEEL WAS VERY NOTCHY AND IT WOULD NOT ROLL IN A CLOCKWISE ROTATION UNLESS MUCH FORCE WAS APPLIED. THE BEARING TYPICAL…