2006 BMW M5 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
What could happen: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.
The fix: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2006 M5.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 12V126000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-525-7417.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Summary: BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
Consequence: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2006 BMW M5 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Airbags (61), Electrical system (22), Engine (13), Transmission / drivetrain (13), Lights (8).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/19/2026 · Electrical system
The contact owns a 2006 BMW M5. The contact stated that while opening the trunk of the vehicle, the positive terminal on the battery was fully melted and was very hot. The contact believed that the issue was a fire hazard and was lucky to have found the issue before any other damage could occur. The contact referenced NHTSA Campaign Number: 12V126000 (Elect…
05/24/2020 · Engine
CLEARANCE FAILURE ON S85 ENGINE TO ROD BEARINGS CAUSES OIL STARVATION. THIS IN TURN CAUSES ENGINE CATASTROPHIC FAILURE. IF DRIVING THIS WILL EFFECT POWER BREAKING, POWER STEERING AND ALL COMPONENTS REQUIRING THE ENGINE TO BE RUNNING. THIS IS A VERY COMMON ISSUE, I NOW HAVE SYMPTOMS REQUIRING A CHANGE OF ROD BEARINGS. *TR
05/24/2019 · Brakes
TL* THE CONTACT OWNS A 2006 BMW 5 SERIES. THE CONTACT STATED THAT THE VEHICLE LEAKED OIL AND THE BRAKES FAILED WHILE DRIVING AT LOW SPEEDS. THE BRAKES WORKED NORMALLY WHEN APPLIED AT HIGH SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A NEW POWER BRAKE BOOSTER AND VACUUM PUMP NEEDED TO BE INSTALLED. THE VEHICLE WAS REPAIRED. THE…
09/18/2017 · Airbags
FRONT PASSENGER SEAT OCCUPANCY DETECTION MAT HAD TO BE REPLACED AS IT WAS DEFECTIVE. THOUGH NOT IN PREVIOUS RECALLS IN SIMILAR BMWS AND SIMILAR YEARS, THE ERROR PRESENTED A SAFETY ISSUE THAT WOULD DISABLE THE FRONT PASSENGER AIR BAGS AND INCREASE THE RISK OF INJURY DURING A CRASH. WITH THIS ERROR, I WAS FORCED TO REPAIR THE SEAT MAT AND EXPENDED $1.5K T…
08/03/2017 · Airbags
UPON STARTING MY CAR, I RECEIVED AN ERROR MESSAGE " FAULT IN PASSENGER RESTRAINT SYSTEM AFFECTING AIR BAGS, BELT TENSIONER OR BELT FORCE LIMITER" THE MESSAGE CONTINUES TO SHOW UP EVERY DAY.. THIS IS THE SAME ISSUE THAT HAS A RECALL IN ALL OTHER 5 SERIES MODELS FOR THIS YEAR, 2006 AND HAS A RECALL FOR THOSE VEHICLES. THIS MODEL SHOULD BE ADDED SINCE ITS THE…
05/08/2017 · Electrical system
NAVIGATION DISPLAY REBOOTS CONSTANTLY. WORKS PERIODICALLY. THIS DISPLAY GIVES ME ACCESS TO ALL OF THE CARS FEATURES INCLUDING WARNINGS AND MALFUNCTIONS WITH THE VEHICLE. IF THE DISPLAY WORKS WHEN THE CAR IS ON IT MAY NOT WORK IF YOU TURN OFF THE CARD AND TURN IT BACK ON.
04/20/2017 · Electrical system
HEAD LIGHTS ANGLE LIGHTS WIRES GETTING VERY DRY FROM THE HEAT OF THE LIGHT AND THE INSULATION COMING OFF THE OPTICAL WIRES, LIGHTS GO OUT, POSSIBLE SHORTING AND BECOME VERY UNSAFE.
02/17/2017 · Transmission / drivetrain
THE EARLY M5 WITH THE SMG (SEQUENTIAL MANUAL GEARBOX) 7 SPEED HAVE NUMEROUS TSB'S AND WARRANTY CAMPAIGNS. THE SHIFTING OF THE GEARBOX IS UP EXECUTED BY PRESSURE FROM THE HYDRUALIC PUMP THAT STORES AAPRX 80PSI IN THE ACCUMULATER. THIS ACCUMULATOR OR PUMP HAS A HI CHANCE OF FAILING AND WHEN IT DOES THE CAR SHUTS DOWN WITHOUT WARNING. MY CAR SHUT DOWN IN T…