1996 Buick Regal recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
What could happen: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
The fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 REGAL.
- Book a repair at any authorized Buick dealer. Quote NHTSA campaign 07E021000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
What could happen: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING.…
The fix: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 REGAL.
- Book a repair at any authorized Buick dealer. Quote NHTSA campaign 03V527000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-608-8080.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING:RACK AND PINION
Summary: CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes: GM RECALL NO. 03062. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
What could happen: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
The fix: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 REGAL.
- Book a repair at any authorized Buick dealer. Quote NHTSA campaign 96V116000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Summary: A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Consequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
Notes: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 3.8L V6 ENGINE. OWNER NOTIFICATION: OWNER NOTIFICATIONS BEGAN DURING JULY 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.
What could happen: THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 REGAL.
- Book a repair at any authorized Buick dealer. Quote NHTSA campaign 96V069000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Summary: THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.
Consequence: THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.
Notes: SYSTEM: BRAKES; HYDRAULIC; LINES. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1996 Buick Regal owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (47), Hydraulic (42), Engine (41), Electrical system (24), Airbags (21).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/02/2019 · Airbags
ON JULY 17, 2019 AT 8:40AM, I GOT INTO MY CAR IN MY DRIVEWAY. I TURNED THE KEY IN THE IGNITION AND THE AIRBAG EXPLODED. (THE CAR WAS NOT STARTED.) THE AIRBAG SOUNDED LIKE A SHOTGUN BEING FIRED AND A POWDER LIKE SUBSTANCE IMMEDIATELY FILLED THE CAR. THE AIRBAG ITSELF HIT ME IN THE ABDOMINAL AREA. I FOUND THE DOOR HANDLE, OPENED THE DOOR, AND ROLLED OUT OF TH…
04/18/2018 · Electrical system
TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT THE BRAKE AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT FACILITY FOR DIAGNOSTIC TESTING AND FAILURE CODES: C1265 (REAR ABS MOTOR CIRCUIT SHORTED TO GROUND) AND C1286 (EBCM/EBTCM FAILED TO ILLUMINATE THE RED BRAKE WARNING INDICATOR) WERE LOCATED. THE VEHICLE WA…
02/06/2016 · Body / structure
DRIVERS SIDE DOOR DOES NOT OPEN FROM INSIDE OR OUTSIDE. THE DOOR DOES NOT WORK WITH KEY EITHER. LOCK SEEMS TO WORKING BUT DOOR DOES NOT OPEN. THE CAR ONLY HAS 60,000 MILES ON IT. THIS IS A VERY COMMON PROBLEM WITH THIS CAR AND SHOULD BE A RECALL.
10/28/2015 · Brakes · fire
WHILE MERGING ONTO THE FREEWAY, I WAS TAKING MY CAR TO BE SMOGGED. AT SPEED, I NOTICED A LITTLE WHITE PUFF OF SMOKE EMIT FROM THE RIGHT SIDE OF THE ENGINE BAY. AS I PROCEEDED TO START MOVING TO THE SHOULDER, THIS PUFF HAD TURNED INTO A GRAY PLUME. AS I FINALLY REACHED THE SHOULDER, THE ENTIRE FRONT OF THE ENGINE BAY WAS BILLOWING BLACK SMOKE. AS I TRIED TO…
04/04/2015 · Engine · fire
MY CAR STARTED TO NOT START AFTER BEING DRIVEN AND SHORTLY AFTER DID NOT WANT TO START IN A SIMPLE IDLE. SOMEHOW FUEL HAS BEEN GETTING TRAPPED IN A PRESSURIZED LINE AND I'M HAVING TO RELEASE THE FUEL OUT. OIL LEAKED INTO THE SPARK PLUGS CAUSED A PILOT FLAME. I HAVE READ MULTIPLE ACCOUNTS OF THIS HAPPENING TO THAT SPECIFIC MAKE AND YEAR AS WELL A FEW OF THE…
02/03/2015 · Steering · crash
1996 BUICK REGAL. CONSUMER STATED THE POWER STEERING WAS NOT CRIMPED PROPERLY. THE BALL BEARING WENT THROUGH THE GEAR BOX WHICH CAUSED THE DRIVER TO LOSE CONTROL OF THE VEHICLE AND CRASHED. THE CONSUMER DISCOVERED THERE WAS A RECALL, ON THE STEERING. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. *JB
06/29/2012 · Airbags
TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT AS THE VEHICLE WAS STARTED, THE AIR BAGS DEPLOYED ERRONEOUSLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 55,035.
07/19/2010 · Airbags
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH, WEN THE FRONT DRIVER SIDE AIR BAG DEPLOYED INADVERTENTLY WITHOUT IMPACT TO THE VEHICLE. THE CONTACT SUSTAINED ABRASIONS TO THE LEFT FOREARM. THE VEHICLE WAS DRIVEN WITH CAUTION TO HIS RESIDENCE. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE VEHICLE HAD…