2003 Chevrolet Astro recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE C…
What could happen: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The fix: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 ASTRO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 06E043000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-890-2075.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
What could happen: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 ASTRO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 06E026000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
3. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.
What could happen: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIO…
The fix: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 ASTRO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 03V328000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.
Consequence: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE IF FORCES RESULTING FROM THE WHEEL'S DRAGGING ACTION WERE SUFFICIENT TO FRACTURE THE TIE ROD END AND UPPER BALL JOINT CONNECTIONS. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL'S HYDRAULIC BRAKE HOSE, RESULTING IN LOST BRAKING PERFORMANCE FROM THE FRONT BRAKE SYSTEM. VEHICLE STOPPING DISTANCE WOULD INCREASE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes: GM RECALL NO. 03044. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2003 Chevrolet Astro owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (27), Hydraulic (21), Electrical system (19), Suspension (9), Transmission / drivetrain (9).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/30/2021 · Suspension
TL* THE CONTACT OWNS A 2003 CHEVROLET ASTRO. THE CONTACT WAS MADE AWARE BY AN INDEPENDENT MECHANIC THAT HIS VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V328000 (SUSPENSION) WHILE PERFORMING ROUTINE MAINTENANCE ON THE VEHICLE. THE VEHICLE WAS DIAGNOSED WITH A FAULTY STEERING KNUCKLE AND LOWER BALL JOINTS. MYRTLE BEACH CHEVROLET (1785 US-501, MYRTLE BEAC…
10/27/2017 · Suspension
FRONT SUSPENSION ISSUES, ELECTRICAL GAUGES, REPLACEMENT OF FUEL TANK PUMP, DOOR LATCHES FAILING TO OPEN ON SLIDING SIDE DOOR MAKING EXITING OF VEHICLE IMPOSSIBLE, RECALL OF 02V328000 UNABLE TO BE CONFIRMED AS HANDLED BY ANY DEALERS.
07/30/2015 · Airbags · crash
2003 CHEVROLET ASTRO CARGO VAN AIR BAG DID NOT DEPLOY AT TIME OF COLLISION. ASTRO VAN WAS HIT ON PASSENGER SIDE, FRONT WHEEL WELL & BUMPER. DRIVER WHO HIT VAN WAS EXCEEDING SPEED LIMIT, APPROXIMATELY DOING CLOSER TO 40 MPH IN A 25 MPH ZONE WHEN THEY HIT OUR VAN. WE WERE JUST STARTING TO PROCEED AFTER A STOP SIGN, BARELY DOING 10 - 15 MPH. THE ASTRO VAN WAS…
05/26/2014 · Brakes
I WAS DRIVING PULLING A TRAILER ON THE FREEWAY WHEN SUDDENLY THE TRAFFIC STOP. I APPLIED THE BRAKES AT A SAFE DISTANCE WHEN SUDDENLY MY BRAKES WHEN ALL THE WAY TO THE FLOOR I APPLIED THE EMERGENCY BRAKES AND STOP. I HAD TO GO THRU THE EMERGENCY LANE. I TOLD MY SON TO PUSH THE BRAKE PEDAL WHILE I WAS UNDERNEATH AND THE BRAKE LINES BROKE. THEY WHERE ALL RUSTE…
04/05/2014 · Steering
MY SPOUSE WAS DRIVING AND WE WERE STOPPED AT A YARD SALE. WE RETURNED TO THE VEHICLE AND STARTED TO BACK OUT WHEN SHE NOTICED THE STEERING WHEEL WAS EXTREMELY HARD TO TURN. THEN WHEN SHE WANTED TO STOP THE VEHICLE THE BRAKES WERE EXTREME HARD TO OPERATE. AFTER SOME RESEARCH WE LEARNED OF HUNDREDS OF BRAKE MALFUNCTIONS ON SIMILAR VEHICLES AND OTHER CARS THA…
10/09/2013 · Brakes
I AM COMPLAINING OF THE SAFETY ISSUES REGARDING THE ABS COMPUTER SYSTEM. I HAVE PUT MY VEHICLE IN THE SHOP TO BE CHECKED OUT BY A FEW CAR REPAIR FACILITIES AND ALL HAVE SAID THE SAME THING MY ABS CPU. MY VAN IS HESITATING TERRIBLY AND CAUSING THE VAN TO NOT ACCELERATE PROPERLY. I HAVE NEARLY BEEN IN THREE ACCIDENTS SINCE THE PROBLEM HAS BEEN OCCURRING. I HA…
07/22/2013 · Electrical system
TL* THE CONTACT OWNS A 2003 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WHILE MAKING A LEFT TURN. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO START WHEN THE VEHICLE WAS PARKED AND THE WHEELS WERE TURNED TO THE LEFT. A MECHANIC LOOKED UNDER THE VEHICLE AND FOUND THAT THE WIRING HARNESS THAT WAS LOCATED NE…
08/18/2012 · Brakes
COMPLETE BRAKE FAILURE DUE TO RUSTING BRAKE LINES. THE PREVIOUS DAY THIS VEHICLE WAS PULLING A SMALL TRAILER ON A MICHIGAN INTERSTATE HIGHWAY. THE FOLLOWING DAY IT WAS PARKED IN MY DRIVEWAY AND A WET AREA WAS VISIBLE ON THE CONCRETE. IT WAS BRAKE FLUID ON THE GROUND THAT HAD DRIPPED FROM THE RUSTED BRAKE LINE AND DRAINED THE MASTER CYLINDER RESERVOIR. I DI…