2008 Chevrolet Aveo recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
What could happen: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
The fix: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevr…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2008 AVEO.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 14V261000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2008 Chevrolet Aveo owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Airbags (70), Electrical system (44), Lights (31), Engine (28), Transmission / drivetrain (15).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
03/22/2026 · Lights
The wiring to my headlights have overheated and melted twice. I found the really on the year and model of my car but wasn't on the list when I entered my vin
09/08/2024 · Engine
California catalytic converter breaking
08/19/2024 · Electrical system · fire
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There…
07/08/2024 · Transmission / drivetrain
The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local mechanic. The cause of the failure was not yet determined. The lo…
10/26/2022 · Transmission / drivetrain
The left side mount-to-mount bracket bolt broke when accelerating normally from a stop. This is one of the bolts that holds the engine to the frame. This caused my shift stick to be thrown back on every acceleration. This is an obvious safety risk. I have not yet had this problem verified or confirmed by anyone. The car seemed to drive well and normal befor…
02/17/2022 · Airbags
The contact's son owns a 2008 Chevrolet Aveo. The contact stated that while her son was driving at an undisclosed speed, the passenger's side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was not mad…
02/01/2022 · Electrical system
In-dash clock module contains the vehicle 'Check Engine Light' - required to pass inspection. Solder joints are defective ('cold' or cracked) creating intermittent electrical connections. Prevents warning of engine defects to driver. Solder defects eventually cause destruction of the module incurring unreimbursed denial of transport and expense to driver to…
08/12/2021 · Lights · fire
The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to disconnect the battery and the smoke had stopped. The contact stated…