1985 Chevrolet Caprice recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-21. Recalls apply to specific VINs — run your VIN to confirm.
5 safety recalls, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE…
What could happen: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
The fix: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 CAPRICE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 07E088000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-890-2075.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT
Summary: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE C…
What could happen: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The fix: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 CAPRICE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 06E043000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-890-2075.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
3. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
What could happen: SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
The fix: INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 CAPRICE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 89V102000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence: SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Remedy: INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes: SYSTEM: CRUISE CONTROL.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
4. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. THE POSITIVE BATTERY CABLE MAY CONTACT THE UPPER CONTROL ARM OR EXHAUST MANIFOLD SHIELD AND EVENTUALLY WEAR THROUGH THE INSULATION AND GROUND THE CABLE. CONSEQUENCE OF DEFECT: THIS COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD CAUSE BURN INJURIES TO OCCUPANTS.
What could happen:
The fix: INSTALL A POSITIVE BATTERY SERVICE KIT.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 CAPRICE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 85V153000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Summary: THE POSITIVE BATTERY CABLE MAY CONTACT THE UPPER CONTROL ARM OR EXHAUST MANIFOLD SHIELD AND EVENTUALLY WEAR THROUGH THE INSULATION AND GROUND THE CABLE. CONSEQUENCE OF DEFECT: THIS COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD CAUSE BURN INJURIES TO OCCUPANTS.
Consequence:
Remedy: INSTALL A POSITIVE BATTERY SERVICE KIT.
Notes: SYSTEM: ELECTRICAL, BATTERY CABLE. VEHICLE DESCRIPTION: FULL-SIZE PASSENGER CARS WITH 4.3L V6 ENGINES.
5. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. THE FUEL FEED AND FUEL RETURN PIPE ASSEMBLIES INCLUDES A HOSE WHICH MAY CONTACT THE POINTED END OF THE RADIATOR SHROUD ATTACHING SCREW. THIS COULD CAUSE A GASOLINE LEAK. CONSEQUENCE OF DEFECT: IF FUEL LEAK DEVELOPS IT COULD RESULT IN AN UNDERHOOD FIRE AND BURN INJURIES TO OCCUPANTS.
What could happen:
The fix: REPOSITION FUEL LINES TO PRECLUDE CONTACT WITH RADIATOR SHROUD ATTACHING SCREW.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 CAPRICE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 85V151000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: THE FUEL FEED AND FUEL RETURN PIPE ASSEMBLIES INCLUDES A HOSE WHICH MAY CONTACT THE POINTED END OF THE RADIATOR SHROUD ATTACHING SCREW. THIS COULD CAUSE A GASOLINE LEAK. CONSEQUENCE OF DEFECT: IF FUEL LEAK DEVELOPS IT COULD RESULT IN AN UNDERHOOD FIRE AND BURN INJURIES TO OCCUPANTS.
Consequence:
Remedy: REPOSITION FUEL LINES TO PRECLUDE CONTACT WITH RADIATOR SHROUD ATTACHING SCREW.
Notes: SYSTEM: FUEL. VEHICLE DESCRIPTION: PASSENGER CARS.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 1985 Chevrolet Caprice owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Wheels / tires (4), Fuel system (1), Gasoline (1), Electrical system (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (5)
01/25/2001 · Wheels / tires
CONSUMER NOTICED NOISE WHILE DRIVING, CONSUMER INSPECTED VEHICLE AND FOUND GENERAL AMERIWAY XT TIRE, P205/70R15, HAD A 9 INCH LONG AND 4 INCH WIDE STRIP OF TREAD MISSING FROM TIRE. *SLC
10/02/2000 · Wheels / tires
THE LEFT REAR FIRESTONE FR721, SIZE 225/70 R15, DOT HYUUF75084, TIRE SEPARATED COMPLETELY AT THE TREAD, CONSUMER STATES THAT THERE ARE 2 OTHER FAULTY TIRES ON VEHICLE, FIRESTONE DEALER WAS CONTACTED AND AGREED TO INSPECT THE SEPARATED TIRE, CONSUMER YET TO COMPLY WITH FIRESTONE DEALER. *TT
10/02/2000 · Wheels / tires
THE LEFT REAR FIRESTONE FR721, SIZE 225/70 R15, DOT HYUUF75084, TIRE SEPARATED COMPLETELY AT THE TREAD, CONSUMER STATES THAT THERE ARE 2 OTHER FAULTY TIRES ON VEHICLE, FIRESTONE DEALER WAS CONTACTED AND AGREED TO INSPECT THE SEPARATED TIRE, CONSUMER YET TO COMPLY WITH FIRESTONE DEALER. *TT
08/21/2000 · Wheels / tires
PE00020; TIRES BOUGHT FROM A FIRESTONE STORE AND WERE NOT ORIGINAL TIRES, 22570R15, DOTHYUUF75084, AN 10/31/94. CHEVROLET CAPRICE 1985. WHILE DRIVING ON THE INTERSTATE FOR ABOUT 3 MILES, COMPLETE TREAD CAME OFF LEFT REAR WHEEL.*AK 2 OTHER TIRES ARE FAULTY, THE TREAD SEPARATION CAUSED DAMAGE TO THE VEHICLE. *SLC
11/18/1998 · Fuel system
WHEN TRYING TO START UP THE VEHICLE SOMETIMES WON'T START. WHEN STARTING UP AND PULLING OUT, THE VEHICLE WILL KEEP CUTTING OFF. AND THE CONSUMER STATES THE FUEL PUMP WAS REPLACED THREE TIMES, AND THE FUEL FILTER /BATTERY WERE ALSO REPLACED THREE TIMES. DEALER CAN'T DETERMINE THE PROBLEM. *AK