1991 Chevrolet Chevrolet Truck recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1991 Chevrolet Chevrolet Truck owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Wheels / tires (5), Transmission / drivetrain (2), Seat belts (2), Engine (1), Brakes (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/02/2004 · Wheels / tires
FIRESTONE STEELEX, LT245/75R16. WHILE DRIVING BETWEEN 55 TO 60 MPH THE PASSENGER REAR TIRE TREAD SEPARATED. IT DAMAGED THE FENDER. DEALER AND FIRESTONE WERE NOTIFIED. NOTE CONSUMER INDICATED THIS VEHICLE WAS CHEYENNE, 1991. *AK
08/13/2003 · Transmission / drivetrain · fire
FIRE STARTED W/ SPILLAGE OF TRANSMISSION FLUID ONTO ENGINE. DIP STICK DID NOT HAVE A LOCKING MECHANISM. DIP STICK WAS MISSING WHEN THE FIRE WAS OUT.*AK
08/04/2002 · Engine
ENGINE NOISE : REPLACE WITH NEW DESIGN CAST IRON EXHAUST MANIFOLD AND STAINLESS STEEL GASKET PER TECHNICAL SERVICE BULLETIN #37-66-02B DATED NOV. 1996 AND COVERING P MODELS WITH 7.4L ENGINES (VIN N - RPOL19) AND CAST IRON EXHAUST MANIFOLDS FOR MODEL YRS. 1982-1995. AN EXHAUST LEAK HAS REOCCURED BETWEEN THE MANIFOLD AND ENGINE BLOCK. AN INDEPENDENT GARAGE…
06/26/2002 · Wheels / tires · crash
ATTORNEY WRITING ON THE BEHALF OF 4 ACCIDENTS IN WHICH HE STATES WERE CAUSED BY TREAD SEPARATION ON GOODYEAR 16 INCH LOAD RANGE E STEEL BELTED RADIAL TIRES, THIS PARTICULAR POLICE REPORT STATES THAT CONSUMER LOST CONTROL OF THE VEHICLE, CAUSING A ROLLOVER IN WHICH THE DRIVER WAS FATALY INJURED DUE TO BEING EJECTED OUT OF THE DRIVERS DOOR WINDOW, OWNER OF VE…
01/17/2001 · Wheels / tires
GOODYEAR WRANGLER AT 16 INCH TIRES EXPERIENCED FAILURE, ONE TIRE EXPERIENCED TREAD SEPARATION, THE OTHER THREE TIRES EXPERIENCED CRACKING, CHIPPING, AND PEELING. *SLC
11/09/1999 · Brakes
THE ANTI-LOCK BREAKS DO NOT WORK. THE FRONT WHEELS WILL LOCK-UP BEFORE THE BACK WILL DO ANYTHING. IT IS HARD TO STOP. WENT TO THE DEALER THEY REPLACED THE BLACK BOX BRAIN AT MY COST ITS NO BETTER. IT HAS BEEN THIS WAY FOR OVER 3 YRS. NOW. I HERD ON THE NEWS THERE WAS A RECALL BUT I CALLED 3 DEALERS AND THEY SAID THEY DON'T KNOW ANYTHING ABOUT IT. I CALLED G…
07/26/1999 · Seat belts
RECALL REPAIR NOT ABLE TO BE COMPLETED PROPERLY IN ADDITION TO OTHER REPAIRS THAT WERE DAMAGES THAT WERE DONE DURING RECALL.
10/12/1997 · Lights
HEADLIGHT ADJUSTMENT MECHANISMS FROZE UP. NACELLES WHERE ADJUSTERS ARE SITUATED MUST BE PURCHASED AS A UNIT, AND THEY COST $158. *AK