2007 Chevrolet Corvette Z06 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
What could happen: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
The fix: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2007 CORVETTE Z06.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 09V491000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:BODY:ROOF AND PILLARS
Summary: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Notes: GM SAFETY RECALL NO. 090230. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2007 Chevrolet Corvette Z06 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (121), Transmission / drivetrain (55), Engine (55), Lights (42), Electrical system (36).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/29/2026 · Transmission / drivetrain
A mismatched gear indicator where the dashboard shows "Park" but the transmission is actually in "Reverse" is dangerous that creates a severe rollaway risk.When this first happened I pulled into my garage and put the car into park and took my foot off brake and with out me realizing the car was moving backwards I nearly ran over someone. Could've been very…
03/30/2026 · Fuel system
The contact owns a 2007 Chevrolet Corvette. The contact stated that while the vehicle was parked at the residence, after exiting the vehicle, the contact became aware of an abnormal fuel odor inside the vehicle. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manuf…
05/20/2025 · Fuel system
Fuel smell - possible fuel leak - the issue had been previously addressed with replacement of fuel subassembly in both saddle tanks. I believe that it is happening again ...
05/19/2025 · Fuel system
There was a strong fuel smell after the last 2 times I drove it. I took it to the shop and they tell me the evap canister was saturated and the fuel pump had small cracks in it likely seeping when the car heats up. I am having the fuel pump replaced, the evap canister and several seals/hoses in hopes it won't leak again.
05/02/2025 · Fuel system
After filling the tank with fuel, I was immediately aware of a strong smell of gas. I am always extremely careful not to overfill causing any fuel to escape. The heavy smell/escape of fumes is such that the car simply can’t be put in my garage. The risk of igniting and fire is a risk that is unacceptable. General Motors knows about this issue as they did no…
11/11/2024 · Fuel system
Fuel smell but no leaks detected, can't store car in garage because of fumes. Worried when driving a fire will occur Had a service bulletin 150682 special vehicle adjustment, need help.
09/30/2024 · Fuel system
Fuel smell inside and outside when car is parked.
06/26/2024 · Visibility (wipers / glass)
The contact owns a 2007 Chevrolet Corvette. The contact stated while starting the vehicle, there was a loud creaking and popping noise coming from the sunroof. The dealer was contacted; however, the vehicle was not repaired. The contact was concerned about the safety of the vehicle. The manufacturer was made of the failure and advised the contact to reach o…