2012 Chevrolet Corvette recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. THE REAR HATCH HINGES MAY NOT MEET THE LOAD REQUIREMENTS SPECIFIED IN THE SAFETY STANDARD.
What could happen: THE REAR HATCH COULD SEPARATE IN THE EVENT OF A CRASH, INCREASING THE RISK OF INJURY.
The fix: GM WILL NOTIFY OWNERS AND DEALERS WILL REPLACE BOTH REAR HATCH HINGES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 CORVETTE.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 11V491000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
Summary: GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET CORVETTE COUPE VEHICLES, MANUFACTURED FROM JANUARY 24, 2011, THROUGH SEPTEMBER 1, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS". THE REAR HATCH HINGES MAY NOT MEET THE LOAD REQUIREMENTS SPECIFIED IN THE SAFETY STANDARD.
Consequence: THE REAR HATCH COULD SEPARATE IN THE EVENT OF A CRASH, INCREASING THE RISK OF INJURY.
Remedy: GM WILL NOTIFY OWNERS AND DEALERS WILL REPLACE BOTH REAR HATCH HINGES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes: GM'S SAFETY RECALL CAMPAIGN NUMBER IS 11258. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (29), Airbags (10), Electrical system (6), Electronic Stability Control (esc) (5), Brakes (4).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
07/02/2026 · Steering
I am reporting a safety issue involving the Active Handling/Stability Control system on my 2012 Chevrolet Corvette. After a routine oil change at Grossman Chevrolet in [XXX] on XXX, the “Service Active Handling System” warning appeared. I called the dealership and was told to cycle the ignition several times to reset it, but the warning stayed on. In early…
06/27/2026 · Fuel system
90 degree elbow on top of fuel hat on drivers side fuel tank cracked and had a bad fuel leak causing an immediate fire hazard in my garage with how combustible fuel is. There were no warning signs just walked into my garage one morning with a very strong smell of gasoline. The issue was dealt with by myself I didn’t have to take it to a mechanic to repair
03/07/2026 · Fuel system
Fuel leak(s) involving filler neck, fuel pump, fuel tank or associated parts in the fuel delivery system at rear of car. Gasoline smells is very strong, when the tank is filled (not overfilling the tank) gasoline puddles under the rear near the driver’s side rear tire. The fumes are so bad that the car cannot be stored in the garage (which is attached to my…
01/29/2026 · Fuel system
I purchased a 2012 Corvette from Coast Chevrolet on 1-24-26. This car was supposed to have been inspected for safety issues prior to being listed for sale. Being that this is a reputable General Motors dealership I assumed all safety issues and recalls would have been up to date. I drove the car home about 90 miles and immediately put it in my garage. After…
11/24/2024 · Fuel system
Recently purchase used car. Very strong a gas smell/fumes in garage whenever fuel is pumped more than 1/2 tank. Concerned over fire or explosion hazard.
04/30/2024 · Fuel system
Smelling gas fumes when parked. There were no other indicators of an issue. I took car to dealership, turns out there is a flaw with the fuel system, causing a leak at the top of the tank. Fuel was leaking through a valve and into the inside of the car frame. This issue should be a recall. The dealer would not let me leave with the vehicle due to the…
01/13/2024 · Fuel system
Fuel smell coming from gas cap area replaced the gas cap twice. Continue to have strong fuel smells in garage where car is kept. Started about one month ago.
11/17/2023 · Fuel system
Strong gas smell after filling gas tank. This is a known issue on these cars and although it can develop at any time they only warranty the problem for 10 years. This creates a fire hazard. The attached service bulletin was just released by GM today: Special Coverage Adjustment 15682 Primary Tank Module Flange Fuel and Vapor Leaks Reference Number: N1506…