2001 Chevrolet Express 3500 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE…
What could happen: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
The fix: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2001 EXPRESS 3500.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 07E088000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-890-2075.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT
Summary: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2001 Chevrolet Express 3500 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (4), Wheels / tires (3), Brakes (2), Hydraulic (2), Electrical system (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
11/28/2017 · Wheels / tires
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 EQUIPPED WITH DEXTERO DHT2 TIRES, SIZE: LT245/75R/16 (NA). WHILE TRAVELING AT HIGHWAY SPEEDS, THE REAR PASSENGER TIRE EXPERIENCED A BLOW OUT. THE VEHICLE WAS TOWED TO AMERICAN CUSTOM TIRE INC (1300 W MAIN ST, QUARTZSITE, AZ) WHERE IT WAS DIAGNOSED THAT THE INTERNAL SIDEWALL FAILED. THE TIRE WAS REPLACED. TH…
06/01/2016 · Electrical system
THE "PCM"-PUMP CONTROL MODULE LOCATED ON THE INJECTION PUMP THAT IS IN CHARGE OF OPERATING AND COORDINATING PUMP OPERATIONS FAILS AFTER 30,000 TO 40,000 MILES. THIS CAUSES THE VEHICLE TO STOP RUNNING--NO BRAKES OR STEERING SIMILAR TO IGNITION SWITCH PROBLEM IN OTHER VEHICLES. GM LIKES TO GET 1,400 TO FIX, AFTER THE TOW. THANKS [XXX] A BETTER FIX NEEDS…
05/17/2016 · Steering
THE REAR MAIN SEAL, FRONT HARMONIC SEAL AND POWER STEERING PUMP SHAFT SEAL ARE LEAKING. THE VEHICLE HAS 96,000 MILES ON IT. THIS SHOULD NOT BE. I TOOK IT TO A SHOP LAST WEEK TO HAVE PROBLEM FIXED. NEED HELP VERY EXPENSIVE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
01/29/2012 · Brakes
BRAKE LINES SEVERELY CORRODED AND RUSTED AT MULTIPLE LOCATIONS. COMPLETE REPLACEMENT IS REQUIRED TO RENEW SAFETY INSPECTION CERTIFICATION.
07/29/2010 · Brakes · crash
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 VAN. THE CONTACT WAS APPROACHING A TRAFFIC STOP WHEN HE APPLIED THE BRAKES. THE BRAKES ENGAGED MOMENTARILY AND THEN INDEPENDENTLY RELEASED. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT STATED THE FAILURE OCCURRED ONCE PRIOR TO THE CRASH. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. T…
07/28/2010 · Engine
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 VAN. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS THE CONTACT WAS COASTING TO A STOP, THE VEHICLE INDEPENDENTLY RESTARTED. THE MANUFACTURER ADVISED THERE WERE NO RECALLS FOR THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR RE…
04/28/2008 · Wheels / tires
TIRE TREAD SEPARATED FROM TIRE CARCASS. *TR
01/23/2007 · Airbags · crash
TL*- THE CONTACT STATED THAT ON 12/14/06 AT 7:30 PM ON A CLEAR EVENING A SECOND VEHICLE RAN A RED LIGHT AND THE CONTACT'S VEHICLE HIT THE OTHER VEHICLE ON THE PASSENGER FRONT SIDE AT 55 MPH WITH THE 2001 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT HE LOST CONTROL OF THE VEHICLE AND HIT A DITCH HEAD ON AT 50 MPH. THE POLICE WERE CALLED, HE DIDN'T S…