1997 Chevrolet G20 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE…
What could happen: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
The fix: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 G20.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 07E088000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-890-2075.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT
Summary: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1997 Chevrolet G20 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (2), Hydraulic (2), Fuel system (1), Other (1), Transmission / drivetrain (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (5)
02/04/2003 · Fuel system
BAD FUEL PUMP ON 1997 CHEVY G20 CONVERSION VAN. BARE WIRES (INSULATION HAD BURN OFF) THE FUEL PUMP WHICH IS LOCATED INSIDE THE FUEL TANK. I CONTACTED GM ABOUT THE PROBLEM, CUSTOMER SERVICE SAID THERE IS NO RECORD OF THIS PROBLEM. THE MECHANIC SAID I WAS LUCKY ME AND MY FAMILY WEREN'T BLOWN UP. I HAVE THE FUEL PUMP AT HOME FOR EXAMINATION OR INSPECTION.
03/09/2001 · Transmission / drivetrain
BESIDES STRANDING ME WHEN THE TRANSMISSION WENT OUT TWICE, LOSING POWER ON THE INTERSTATE IN BUMPER TO BUMPER TRAFFIC IS HAZARDOUS. BUT TWICE I NEARLY CRASHED WHEN THE POWER STEERING WENT OUT, IN A CURVE ON THE INTERSTATE. THE VAN IS A HORSE TO MUSCLE AND THE SUDDEN LOSS OF STEERING NEARLY COST ME CONTROL OF THE VEHICLE. I'M SURE IF MY WIFE OR DAUGHTER WER…
03/05/2001 · Brakes
WHILE DRIVING, VEHICLE WOULD WANDER SIDE TO SIDE AND PULL TO SIDE. SOMETIMES COULD FLIP OVER. THEN, TOOK VEHICLE TO DEALER , AND THEY FOUND TREAD SEPARATION. FIRESTONE, FIREHAWK TIRES. *AK CONSUMER STATES WHEN VEHICLE WAS TAKEN IN FOR REGULAR MAINTENANCE IT WAS DISCOVERED THAT ALL FOUR TIRES WERE FOUND TO HAVE BROKEN BELTS AND TIRES WERE UNABLE TO BE RO…
04/21/1998 · Brakes
BRAKES FAILED.
07/02/1997 · Body / structure
SUNVISOR ON DRIVER'S SIDE AND INSIDE DOOR HANDLE BROKE. *AK