1994 Chevrolet Lumina Apv recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Transmission / drivetrain
What's wrong, in plain English: The parts that send engine power to the wheels. Failure can mean a sudden loss of power or the car rolling away. VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
What could happen: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
The fix: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 LUMINA APV.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 96V015000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Consequence: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
Notes: SYSTEM: POWER TRAIN; TRANSMISSION; AUTOMATIC; COOLING UNIT AND LINES. VEHICLE DESCRIPTION: PASSENGER MINI-VANS WITH 3.8L ENGINE AND 4-SPEED AUTOMATIC TRANSMISSIONS AND PASSENGER VEHICLES WITH L27 OR L67 ENGINE AND 4T60E AUTOMATIC TRANSMISSIONS AND SOLD OR REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, VERMONT, WEST VIRGINIA, WISCONSIN AND WYOMING. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. THE THIRD ROW SAFETY BELT RETRACTORS MAY BE INSTALLED INCORRECTLY AND MAY LOCK-UP WHEN THE VEHICLE IS ON SLOPES OF LESS THAN 15 DEGREES, WHICH DOES NOT COMPLY WITH FMVSS NO. 209, "SEAT BELT ASSEMBLIES."
What could happen: CONSEQUENCE OF NON-COMPLIANCE: PASSENGERS SEATED IN THESE POSITON MAYBE UNABLE TO EXTRACT AND FASTEN THEIR SEAT BELTS UNTIL THE VEHICLE IS MOVED TO A MORE LEVEL SURFACE. UNBELTED OCCUPANTS ARE MORE AT RISK OF INJURY IN THE EVENT OF A COLLISION THAN THOSE USING SAFETY BELTS.
The fix: DEALERS WILL REMOVE THIRD ROW SAFETY BELT RETRACTORS AND REINSTALL THEM PROPERLY.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 LUMINA APV.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 94V015000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:RETRACTOR
Summary: THE THIRD ROW SAFETY BELT RETRACTORS MAY BE INSTALLED INCORRECTLY AND MAY LOCK-UP WHEN THE VEHICLE IS ON SLOPES OF LESS THAN 15 DEGREES, WHICH DOES NOT COMPLY WITH FMVSS NO. 209, "SEAT BELT ASSEMBLIES."
Consequence: CONSEQUENCE OF NON-COMPLIANCE: PASSENGERS SEATED IN THESE POSITON MAYBE UNABLE TO EXTRACT AND FASTEN THEIR SEAT BELTS UNTIL THE VEHICLE IS MOVED TO A MORE LEVEL SURFACE. UNBELTED OCCUPANTS ARE MORE AT RISK OF INJURY IN THE EVENT OF A COLLISION THAN THOSE USING SAFETY BELTS.
Remedy: DEALERS WILL REMOVE THIRD ROW SAFETY BELT RETRACTORS AND REINSTALL THEM PROPERLY.
Notes: SYSTEM: INTERIOR SYSTEMS; ACTIVE RESTRAINTS; BELT RETRACTORS. VEHICLE DESCRIPTION: PASSENGER VANS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-222-1020, OLDSMOBILE SERVICE CENTER AT 1-800-442-6537, OR PONTIAC SERVICE CENTER AT 1-800-762-2737. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. THE SECOND ROW, RIGHT HAND SHOULDER BELT CAN BECOME "PINCHED" BETWEEN THE SEAT AND THE DOOR FRAME PILLAR TRIM. THE SHOULDER BELT MAY NOT RETRACT PROPERLY, WHICH DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE 1994 VEHICLES HAVE AN OPTIONAL INTEGRAL (BUILT IN) CHILDSEAT INSTALLED NEXT TO THE POWER SLIDING SIDE DOOR. THE 1993 INVOLVED VEHICLES HAVE STANDARD SEATS IN THAT SAME P…
What could happen: IMPROPER SHOULDER BELT RETRACTION DOES NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR COLLISION.
The fix: DEALERS WILL REPLACE THE DOOR FRAME PILLAR TRIM PANEL WITH A REDESIGNED TRIM PANEL. ALSO, A CAUTION LABEL WILL BE APPLIED TO THE CHILD SEAT ADVISING THE OWNER NOT TO INSTALL THE SEAT TO THE PASSENGER SIDE OF A VEHICLE WITH A POWER SLIDING SIDE DOOR.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 LUMINA APV.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 94V100000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:WEBBING
Summary: THE SECOND ROW, RIGHT HAND SHOULDER BELT CAN BECOME "PINCHED" BETWEEN THE SEAT AND THE DOOR FRAME PILLAR TRIM. THE SHOULDER BELT MAY NOT RETRACT PROPERLY, WHICH DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE 1994 VEHICLES HAVE AN OPTIONAL INTEGRAL (BUILT IN) CHILDSEAT INSTALLED NEXT TO THE POWER SLIDING SIDE DOOR. THE 1993 INVOLVED VEHICLES HAVE STANDARD SEATS IN THAT SAME POSITION.
Consequence: IMPROPER SHOULDER BELT RETRACTION DOES NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR COLLISION.
Remedy: DEALERS WILL REPLACE THE DOOR FRAME PILLAR TRIM PANEL WITH A REDESIGNED TRIM PANEL. ALSO, A CAUTION LABEL WILL BE APPLIED TO THE CHILD SEAT ADVISING THE OWNER NOT TO INSTALL THE SEAT TO THE PASSENGER SIDE OF A VEHICLE WITH A POWER SLIDING SIDE DOOR.
Notes: SYSTEM: INTERIOR SYSTEMS; SHOULDER BELTS. VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH OPTIONAL POWER SLIDING DOOR. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-424-9393; PONTIAC SERVICE CENTER AT1-800-762-2737; OR OLDSMOBILE SERVICE CENTER AT 1-800-442-6537. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. THE SAFETY BELT RETRACTORS FOR THE REAR CENTER POSITION ARE MISSING A PAWL SPRING AND IN CASE OF AN ACCIDENT, WILL ALLOW THE SAFETY BELT WEBBING TO EXTEND BEYOND THE MINIMUM REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
What could happen: IN THE EVENT OF AN ACCIDENT THE SAFETY BELT WOULD NOTRESTRAIN THE OCCUPANT, SUBJECTING THE OCCUPANT TO INCREASED RISK OF INJURIES.
The fix: DEALERS WILL INSPECT THE SAFETY BELT RETRACTOR ASSEMBLY AND REPLACE THE RETRACTOR IF THE PAWL SPRING IS MISSING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 LUMINA APV.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 93V212000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:REAR/OTHER
Summary: THE SAFETY BELT RETRACTORS FOR THE REAR CENTER POSITION ARE MISSING A PAWL SPRING AND IN CASE OF AN ACCIDENT, WILL ALLOW THE SAFETY BELT WEBBING TO EXTEND BEYOND THE MINIMUM REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence: IN THE EVENT OF AN ACCIDENT THE SAFETY BELT WOULD NOTRESTRAIN THE OCCUPANT, SUBJECTING THE OCCUPANT TO INCREASED RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE SAFETY BELT RETRACTOR ASSEMBLY AND REPLACE THE RETRACTOR IF THE PAWL SPRING IS MISSING.
Notes: SYSTEM: INTERIOR SYSTEMS; SAFETY BELTS; LAP; REAR; FMVSS 208.VEHICLE DESCRIPTION: VANS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT CHEVROLET SERVICE CENTER AT 1-800-222-1020; PONTIAC SERVICE CENTER AT1-800-762-2737; OR OLDSMOBILE SERVICE CENTER AT 1-800-442-6537. ALSO, CONTACTTHE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1994 Chevrolet Lumina Apv owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Seat belts (16), Brakes (13), Hydraulic (12), Electrical system (10), Transmission / drivetrain (9).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
11/15/2010 · Steering
CATASTROPHIC SUB FRAME FAILURE. AFTER 16 YEARS OF SALTED NE OHIO ROADS THE VAN'S FRONT SUB FRAME COLLAPSED AND MADE THE VEHICLE UNSAFE TO DRIVE. IT WOULD JOLT FROM LANE TO LANE WHILE SHIFTING, AND HAD LOST MOST STEERING CONTROL. MECHANICS REPLACED OVER $700 OF PARTS TRYING TO FIX THE ISSUE UNTIL A FRIEND FOUND THE REAL CULPRIT OF THE CLUNKING AND LOST ST…
06/27/2010 · Brakes
I OWN TWO VERY SIMILAR GM MADE VANS, A 1996 OLDSMOBILE SILHOUETTE, AND A 1994 CHEVROLET LUMINA APV VAN. BOTH HAD SUDDEN BRAKE FAILURE DUE TO THE REAR BRAKE LINE BURSTING, IN EXACTLY THE SAME PLACE! BOTH HAD CURRENT INSPECTIONS. THIS IS VERY DANGEROUS. I HAD TO REPLACE THE REAR BRAKE LINES ON BOTH VANS. THE FACT THAT THEY FAILED AT EXACTLY THE SAME POIN…
09/09/2005 · Transmission / drivetrain
DT: THE CONTACT STATES TRANSMISSION STILL ACTS LIKE IT WANTS TO OVERHEAT. THE TRANSMISSION WAS REPLACED ON JAN 5TH THE LINES ARE LEAKING. THE CONTACT FEELS THIS IS RELATED TO RECALL 96V015000. THE CONTACT HAS NEVER RECEIVED A RECALL LETTER. THE VEHICLE HAS 202,000 MILES ON IT. ALSO, THE FRONT AND MIDDLE SEAT BELTS ARE NOT RETRACTING. THE WEBBING IS COM…
03/10/2004 · Airbags · fire
I WAS READING INFORMATION ON THE FOLLOWING: NHTSA ACTION NUMBER : PE95062 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE : CHEVROLET MODEL: LUMINA APV MANUFACTURER : GENERAL MOTORS CORP. YEAR : 1994 COMPONENT : ELECTRICAL SYSTEM:WIRING MY 1994 LUMINA APV STARTED TO SMOKE IN THE STEERING COLUMN ON 2 OCCASIONS. I TURNED OFF THE IGNITION KEY AND IT STOPPED…
03/08/2004 · Visibility (wipers / glass)
I HAVE A 1994 CHEVROLET LUMINA APV. BACK IN 2000 I HAD THE WINDSHIELD WASHER MOTOR/ASSEMBLY REPLACED BECAUSE OF FAILURE TO OPERATE ON NUMEROUS OCCASIONS. IN THE PAST TWO YEARS GM HAS ISSUED A REPAIR/REFUND FOR SAME MOTOR FOR ALL OTHER VEHICLES WITH PROBLEMS BUT NOT FOR THE LUMINA/LUMINA APV. THIS WAS A COSTLY REPAIR AND WOULD LIKE TO KNOW WHAT GM IS GOIN…
07/25/2003 · Visibility (wipers / glass)
I OWN A 1994 CHEVROLET LUMINA VAN AND THE WINDSHIELD WIPERS WORK ONLY WHEN THEY "FEEL LIKE IT". IN SPEAKING TO AN INDEPENDENT MECHANIC (NOT A CHEVY DEALERSHIP), HE MENTIONED THAT THIS IS THE SAME WINDSHIELD WIPER ASSEMBLY THAT IS ON YOUR RECALL 98V150001, HOWEVER, THIS VEHICAL IS NOT LISTED AS PART OF THAT RECALL. UPON CONTACTING CHEVY, THEY USED THAT SAM…
05/30/2003 · Steering
VEHICLE STEERING COLUMN WAS MADE OF ALUMINIUM INSTEAD OF STEEL. *MR
01/29/2003 · Airbags
COLLIDED HEAD-ON INTO A TREE AND THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. PH