1998 Chevrolet Lumina recalls & complaints

Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: ENGINE AND ENGINE COOLING
Summary: GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes: GM RECALL NO. 09047. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: STEERING:RACK AND PINION
Summary: CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes: GM RECALL NO. 03062. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

03/08/2020 · Lights
THIS PROBLEM EXISTS BWHEN THE VEHICLE IS SATIONARY AND IN TRANSIT. IT APPEARS TO BE INTERMITTEN AS WELL. MY BRAKE LIGHTS WORK WHEN I AM BRAKING, BUT THEY SEEM TO INTERMITTENLY BE FAILING WHEN I USE MY DIRECTIONAL SWITCH (4 WAY). I HAVE BEEN ADVISED ON 3 OCCASSIONS, TWICE BY SHERIFF'S DEPUTIES THAT MY BRAKE LIGHTS ARE NOT WORKING. BUT THEY DO WORK EXCEPT WH…

12/09/2018 · Unknown Or Other
I WAS FORCED TO DRIVE THIS COMPANY VEHICLE BY NEW TRANSPORTATION MANAGER, EVEN THOUGH I HAD ANOTHER COMPANY VEHICLE ASSIGNED TO ME TO DRIVE. FROM 11/9/2018 TO 11/13/2018 I WORKED OVERTIME PLUS MY REGULAR WEEK OF WORK. IT WAS THE FIRST TIME USING THE HEATER IN THIS VEHICLE AND I WAS WORKING LONG HOURS WITH THE HEATER ON BECAUSE THE WEATHER HAD CHANGED. ON…

07/31/2017 · Airbags · crash
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE DRIVING APPROXIMATELY 28-30 MPH, ANOTHER MOTORIST MADE AN OUT OF TURN LEFT TURN IN FRONT OF THE CONTACT'S VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO THE FRONT DRIVER'S SIDE OF THE OTHER VEHICLE. THE AIR BAG INDICATOR ILLUMINATED, BUT THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS INOPERABLE. THE CONTACT…

04/07/2017 · Lights
WE BOUGHT THE CAR USED. AT TIME OF PURCHASE BRAKE LIGHTS APPEARED TO WORK. SAME EVENING, THE TWO REAR/SIDE BRAKE LIGHTS DID NOT WORK (THE THIRD/MIDDLE LIGHT WORKS). WE DID SOME TROUBLE SHOOTING, REPLACED BULBS, CHECKED FOR SHORTS. IN OUR RESEARCH WE FOUND THAT THIS IS IN FACT A COMMON PROBLEM AMONG GM SEDANS AND IS CAUSED BY FAILURE OF THE MULTIFUNCTION…

03/21/2017 · Steering
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THERE WAS A RANDOM POWER STEERING LEAK. THE PREVIOUS OWNER HAD TO REPLACE THE FLUID CONSTANTLY. WHEN A MECHANIC REPLACED THE STEERING PUMP, THE FAILURE CONTINUED. THE MECHANIC INFORMED THE PREVIOUS OWNER THAT THE STEERING RACK MAY NEED TO BE REPLACED. THE CONTACT HAD ALSO TAKEN THE VEHICL…

02/18/2017 · Airbags
TAKITA RECALL AIRBAG MAY BE THE CAUSE OF PASSENGER SIDE DASH EXPANDING OUTWARDS. UNSURE OF CAUSE. EXPANSION IS SLOWING COMING OUT OF SEM. HAVE NOTICED APPROXIMATELY TWO YEARS ONGOING.

01/03/2017 · Engine
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE REMEDY CAUSED OTHER ISSUES WITH THE VEHICLE. WHEN THE VEHICLE WAS STARTED, SMOKE APPEARED UNDER THE HOOD AND THE CONTACT NOTICED A CRACK IN THE VACUUM HOSE. THE VEHICLE WAS TAKEN BACK T…

12/18/2016 · Airbags
DASH AIRBAG IS PROTRUDING OUT. VECHILE STATIONARY. SEE PHOTOS.