2002 Chevrolet Malibu recalls & complaints

Component: ELECTRICAL SYSTEM:IGNITION
Summary: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

07/15/2026 · Electrical system
Odometer Fraud. The contact purchased a 2002 Chevrolet Malibu. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the independent mechanic, who reported the mileage at 105,000. The key was stuck in the ignition, but was replaced. It was discovered that there was a mileage discrepancy. The vehicle was a private s…

08/18/2021 · Electrical system
The anti-theft/ passlock system fault in this generation of GM vehicles is very widespread and effects a large percentage of vehicles in this generation. I am sure there have been hundreds if not thousands of complaints about same issue and GM refuses to fix the problem. The problem causes the car to randomly shut off due to anti theft fault and can happen…

09/13/2020 · Electrical system
THE TURN SIGNALS WORK SOMETIMES AND SOMETIMES THEY DON'T WORK. I RESEARCHED THIS ON THE INTERNET AND IT SEAMS TO BE A SERIOUS PROBLEM WITH THIS CAR MAKE. IF THERE ARE NO RECALLS ON THIS THERE SHOULD BE. THIS IS A MAJOR SAFETY HAZARD. I JUST BOUGHT THIS CAR FOR MY TEENAGE SON.

09/07/2020 · Brakes
THE HYDRAULIC BRAKE LINES BETWEEN THE FRONT AND REAR OF THE CAR CORRODED AND QUICKLY LEAKED FLUID OUT SO THE BRAKES NO LONGER FUNCTIONED. THE FLUID LEAKED OUT WHEN THE CAR WAS PARKED AFTER DRIVING ON THE HIGHWAY THE NIGHT BEFORE. IF THIS HAPPENED WHEN I WAS DRIVING THE RESULTS COULD HAVE BEEN CATESTOPHIC MY MECHANIC STATED THAT THIS IS A COMMON PROBLEM WI…

09/22/2019 · Electrical system
THE CHARACTERISTICS OF THE PROBLEM ARE AS FOLLOWS: THE ENGINE JUST DIES RANDOMLY. WHEN THE ENGINE DIES, I NOTED THE GAUGES ALL INDICATED THE KEY WAS IN THE OFF POSITION, EVEN THOUGH THE KEY HAD NOT BEEN TOUCHED. THEY BY TURNING THE KEY TO THE OFF POSITION AND WIGGLING IT ONLY AFTER BRINGING THE VEHICLE TO A COMPLETE STOP AND PUTTING THE GEAR SHIFT IN THE P…

06/19/2019 · Electrical system
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE HESITATED WHEN STARTED. ALSO, THE INSTRUMENT PANEL LIGHTING BECAME VERY DIM AND THE DATA ON THE SCREEN WAS NOT VISIBLE. ALSO, THE PASSENGER DOOR WOULD NOT LOCK AND THE WINDOWS FAILED TO ROLL DOWN. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT JUMPE…

02/18/2019 · Electrical system
PASSLOCK CENSOR IN THE IGNITION LOCK CYLINDER FAILING. SECURITY RELEARN NEEDED. VEHICLE WAS STATIONARY.

11/15/2018 · Electrical system
CAR WOULD NOT START, HAD TO REPLACE ALTERNATOR. ONE WEEK LATER SAME PROBLEM, HAD A MECHANIC CHECK IT NOW SAYING ITS THE BATTERY SO REPLACED THAT. WAS STARTING OK THEN IT WOULDN'T START SO WE WIGGLED KEY AROUND AND IT STARTED. WAS ABLE TO DRIVE SEVERAL DAYS DOING THIS BUT THEN IT WOULD NOT START AT ALL. THE MECHANIC SAYS IT IS THE IGNITION SWITCH. WHEN I LOO…