2007 Chevrolet Silverado 3500 recalls & complaints

Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Summary: General Motors LLC (GM) is recalling certain 2007-2008 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the front passenger or other occupants resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began February 11, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-866-522-9559. GM's number for this recall is N192290990.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EQUIPMENT:APPLIANCE:AIR CONDITIONER
Summary: CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Consequence: THIS DEFECT COULD RESULT IN A FIRE.
Remedy: CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
Notes: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: ELECTRICAL SYSTEM
Summary: General Motors LLC (GM) is recalling certain model year 2007-2011 Chevrolet Silverado HD 2500/3500 trucks manufactured January 18, 2007, to June 22, 2011, and GMC Sierra HD 2500/3500 trucks manufactured January 22, 2007, to June 21, 2011, and equipped with an auxiliary battery. Owners may unknowingly draw too much current through the vehicle's trailer harness resulting in the melting of fusible link for the auxiliary battery.
Consequence: If the fusible link melts it may come into contact with adjacent components, damage the electrical center cover, the nearby wiring harness conduit and other vehicle components, increasing the risk of a fire.
Remedy: GM will notify owners and dealers will replace the jumper harness with one that includes a 40 amp inline fuse, and provide the owner with supplemental Owner Manual information, free of charge. The recall began on August 29, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14260.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Summary: General Motors LLC (GM) is recalling certain model year 2007-2008 Chevrolet Silverado 2500HD and 3500HD trucks manufactured November 28, 2006, to August 29, 2008, and 2007-2008 GMC Sierra 2500HD and 3500HD trucks manufactured November 27, 2006, to August 29, 2008. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on July 27, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's numbers for this recall are 15438 and 15817.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: ELECTRICAL SYSTEM
Summary: GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

06/03/2026 · Engine · fire
The contact owned a 2007 Chevrolet Silverado. The contact stated that while driving at 65 MPH, the contact noticed smoking coming from the under the front vehicle. The contact mention he pulled over the right side of the road, turned the vehicle off and then exited the vehicle and opened the hood of the vehicle and noticed flames coming from the back of th…

12/16/2024 · Steering
I purchased my new 2007 Chevy duramax diesel with an already installed fabtech lift kit. My pitman arm has snapped 3 times since I purchased my truck leaving me with complete steering loss. I have had to replace all steering components several times. My truck is unsafe due to a fabtech lift kit that the dealer installed before I purchased it. Led Schwab was…

08/21/2023 · Steering
Rattling noise in intermediate shaft of steering column and key tumbler is sticky

08/14/2020 · Fuel system
TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE REFUELING, DIESEL FUEL SPRAYED BACK OUT OF THE FILLER NECK. THE CONTACT WAS CONCERNED THAT THE DESIGN OF THE FILLER NECK TO THE FUEL TANK WAS DEFECTIVE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT WAS UNABLE TO REACH THE MANUFACTURER.…

09/11/2019 · Brakes
WHILE DRIVING AT ABOUT 35 MPH, I HAD TO STOP FOR A GARBAGE TRUCK DOING A TRASH PICKUP. WHEN I APPLIED THE BRAKES ON MY PICKUP, THE BRAKES TOTALLY FAILED AND I NEARLY DROVE ANOTHER CAR INTO THE BACK OF THE GARBAGE TRUCK. THAT AVERTED CRASH WOULD CERTAINLY HAVE KILLED THE CAR'S DRIVER. I AVOIDED A CRASH BY A RAPID TURN INTO THE ONCOMING LANE JUST AS A CAR…

04/07/2019 · Steering
WHILE DRIVING AT ANY SPEED, STEERING WHEEL SHAKES, SLIGHTLY, YET NOTICEABLY. ANY SPEED. THE SHAKE IS CONSISTENT, FEELS WORSE WHEN TURNING OR(DRIFTING) RIGHT I ON FREEWAY. HAVE HAD STEERING GEAR BOX, PITMAN ARM, AND ROAD FORCE BALANCING PERFORMED, TO NO RELIEF. UPON SELF INSPECTION, LEFT WHEEL SEEMS (TIGHTER) AND NOT AS LOOSE TO HAND MANIPULATION, RIGHT WHEE…

05/01/2018 · Unknown Or Other
TAKATA RECALL MY DASHBOARD HAS CRACKED IN THREE DIFFERENT SPOTS 2 AROUND PASSENGERS AIR BAG ONE OVER GAGE CLUSTER. NOT SURE IF CAR WAS IN MOTION OR SITTING WHEN IT HAPPEN.

02/16/2017 · Airbags
"TAKATA RECALL" - I RECEIVED MY LETTER REGARDING THE PASSENGER SIDE AIRBAG RECALL DATED JULY 2015. I CONTACTED CORPORATE HEADQUARTERS AND THEY WERE NO HELP AND KEPT TELLING ME THE VEHICLE WAS "SAFE" TO DRIVE EVEN THOUGH THE LETTER SAYS DISCHARGE OF THE AIRBAG COULD CAUSE "INJURY OR DEATH TO OCCUPANTS." ON 2/15/17 I TOOK THE VEHICLE IN TO BLADE CHEVROLET…