2011 Chevrolet Volt recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
What could happen: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
The fix: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2011 VOLT.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 15V145000 (manufacturer code 14617).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-1020.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:IGNITION
Summary: General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Portable jump starter
- 2011 Chevrolet Volt owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (23), Airbags (8), Fuel system (6), Engine (4), Brakes (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/20/2025 · Lights
The contact owns a 2011 Chevrolet Volt. The contact stated that water was accumulating inside the driver's side taillight assembly. The contact stated that the water caused a short circuit in the taillight, and the passenger’s side turn signal became inoperable. The contact had taken the vehicle to an independent mechanic where it was diagnosed, and determi…
08/04/2025 · Brakes · crash
I was stopped at a red light with my foot on the brake. When the light turned green, I released the brake and the car suddenly accelerated forward on its own, without me touching the accelerator. As soon as the car surged forward, I immediately pressed the brake pedal hard to stop it but instead of slowing down, the car continued to accelerate. It felt lik…
04/26/2024 · Electrical system
Driver display is blank (no speed, gear position, odometer, gas tank, etc), with the exception of some warning icons like tire pressure and passenger seat belt status. Does no return after turning off power.
01/20/2024 · Steering
'11 Chevy Volt hybrid was daily driver of 100+ miles, multiple trips both highway and city for last 2 1/2 months. Breaks and rotors have been replaced all the way around, fresh oil changes as needed and filters. Warning on dash "Service High Voltage Charging System", ”Service Airbag" and check engine light have been on since I've owned it (Oct. 23). When p…
12/29/2023 · Fuel system
The car quit running when my wife was driving the car when the mileage range went down to 4 miles range remaining. The car was towed to the local Chevrolet dealership who charged over $1,000 to reset the electronics so car would run. I was advised that if battery range was run down to a low mileage range that car would quit running again and that it would…
09/14/2023 · Engine
The contact owns a 2011 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the contact heard an abnormal whining sound coming from the engine compartment. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage w…
12/16/2022 · Visibility (wipers / glass)
The contact owns a 2011 Chevrolet Volt. The contact stated that while driving at 35 MPH, the defroster failed to operate as needed. The vehicle was taken to the dealer, and the dealer replaced the heating system module; however, the failure recurred. The vehicle was taken back to the dealer, but the dealer was unable to duplicate the failure. The failure mi…
06/16/2022 · Brakes
Several times over the 2 years I have owned this vehicle while driving an almost complete loss of braking occurs with a service notice for the ABS system. If you turn off the ignition and restart it the braking works fine. I am in the process of having the Electronic Brake Control Module - GM (84070136) and the Brake Pressure Modulator Valve - GM (23283683)…