1991 Chrysler New Yorker recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. WATER LEAKING UNDER WINDSHIELD COWL IN AREA ABOVE HEATER BLOWER MOTOR RESISTOR BLOCK RESULTS IN CORROSION OF THE RESISTOR TERMINALS.
What could happen: CORROSION OF THE RESISTOR TERMINALS INCREASES ELECTRICALRESISTANCE, LEADING TO OVERHEATING AND POSSBLE IGNITION OF THE WIRING CONNECTORSAND INSULATION, CAUSING A FIRE IN THE COWL AREA.
The fix: THE BLOWER MOTOR RESISTOR BLOCK WILL BE REPLACED, AND A MASTIC PATCH APPLIED TO SEAL THE COWL AGAINST WATER ENTRY. DAMAGED WIRE CONNECTORS WILL BE REPLACED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1991 NEW YORKER.
- Book a repair at any authorized Chrysler dealer. Quote NHTSA campaign 91V004000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
Summary: WATER LEAKING UNDER WINDSHIELD COWL IN AREA ABOVE HEATER BLOWER MOTOR RESISTOR BLOCK RESULTS IN CORROSION OF THE RESISTOR TERMINALS.
Consequence: CORROSION OF THE RESISTOR TERMINALS INCREASES ELECTRICALRESISTANCE, LEADING TO OVERHEATING AND POSSBLE IGNITION OF THE WIRING CONNECTORSAND INSULATION, CAUSING A FIRE IN THE COWL AREA.
Remedy: THE BLOWER MOTOR RESISTOR BLOCK WILL BE REPLACED, AND A MASTIC PATCH APPLIED TO SEAL THE COWL AGAINST WATER ENTRY. DAMAGED WIRE CONNECTORS WILL BE REPLACED.
Notes: SYSTEM: HEATER BLOWER MOTOR RESISTOR BLOCK.VEHICLE DESCRIPTION: PASSENGER CARS WITHOUT AUTOMATIC TEMPERATURE CONTROLSYSTEM.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
What could happen: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBUR…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1991 NEW YORKER.
- Book a repair at any authorized Chrysler dealer. Quote NHTSA campaign 96V099000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Summary: THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.
Notes: SYSTEM: BRAKES; HYDRAULIC; ANTI-SKID SYSTEM. VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI-VANS EQUIPPED WITH ANTI-LOCK BRAKE SYSTEMS (ABS). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.
What could happen: FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.
The fix: REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1991 NEW YORKER.
- Book a repair at any authorized Chrysler dealer. Quote NHTSA campaign 91V191000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Summary: THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.
Consequence: FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.
Remedy: REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.
Notes: SYSTEM: BRAKES.VEHICLE DESCRIPTION: PASSENGER CARS AND VANS WITH ANTI-LOCK BRAKE SYSTEMS (ABS).
4. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. FRONT OUTBOARD SAFETY BELT MAY BECOME DIFFICULT TO LATCH AND OR UNLATCH DUE TO A WEBBING STIFFENER ENTERING THE BUCKLE HOUSING AND DISLODGING THE BUCKLE LATCH GUIDE.
What could happen: LATCH MAY OPEN DURING ACCIDENT OR SUDDEN STOP, EXPOSINGSEAT OCCUPANT TO INCREASED RISK OF INJURY.
The fix: REPLACE BUCKLE LATCH ENGAGEMENT.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1991 NEW YORKER.
- Book a repair at any authorized Chrysler dealer. Quote NHTSA campaign 91V122000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:ANCHORAGE
Summary: FRONT OUTBOARD SAFETY BELT MAY BECOME DIFFICULT TO LATCH AND OR UNLATCH DUE TO A WEBBING STIFFENER ENTERING THE BUCKLE HOUSING AND DISLODGING THE BUCKLE LATCH GUIDE.
Consequence: LATCH MAY OPEN DURING ACCIDENT OR SUDDEN STOP, EXPOSINGSEAT OCCUPANT TO INCREASED RISK OF INJURY.
Remedy: REPLACE BUCKLE LATCH ENGAGEMENT.
Notes: SYSTEM: SAFETY BELT.VEHICLE DESCRIPTION: PASSENGER VEHICLE.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1991 Chrysler New Yorker owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (28), Fuel system (28), Gasoline (27), Hydraulic (26), Steering (14).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
01/24/2015 · Electrical system
ALWAYS OVERHEATED,WOULD SMELL HOT RUBBER(WIRING?)THEN COULDN'T START AND PUT IN NEW IGNITION(EARLIER NEW SHIFT COLUMN)2OTHER IGNITIONS FOLLOWED.(INITIAL$266.00)CAUSED KEY FAILURES? SUDDEN ALARMS.WHEN DOOR KEY FAILED,LOCKSMITH COULD NOT HELP,ALARM IN IGNITION,THUS 3 IGNITIONS.ALARM TRIGGERED IN EARLY AMS LEAVING BATTERY DEAD,ALARM=NO START.FINALLY NO ALARM A…
03/15/2010 · Fuel system
I AM REPORTING A PROBLEM WHICH MAY RELATE TO ACCELERATION DUE TO COMPUTER FAILURE. MY 1991 CHRYSLER NEW YORKER REVVED UP CONSIDERABLY AS I SAT IN NEUTRAL AFTER TRAVELING AT 45 TO 50 MPH FOR 7 HOURS. I WAS DRIVING FROM RICHMOND, VA TO ALBANY, GA AND SETTING THE PACE FOR A RENTAL TRUCK ON A VERY WINDY DAY. IT ONLY HAPPENED ON THE ONE DAY. I NO LONGER OWN THE…
10/28/2005 · Brakes
DT: THE CONSUMER STATED ONE YEAR AGO HAD RECALL 96V099000 REPAIR WORK DONE ON THE ABS. SHE WAS EXPERIENCING THE SAME PROBLEMS NOW. THE ABS LIGHT CAME ON, AND THE BRAKES MADE A GRINDING NOISE WHEN STOPPING. THE DEALER TOLD THE CONSUMER THAT INDICATED THAT THE PUMP WAS BROKE. THE PARTS HAVE BEEN ON BACK ORDER SINCE 6-05. THE LAST TIME SHE TALKED TO TH…
05/25/2005 · Airbags
I HAVE A 1992 CHRYSLER NEW YORKER. I WAS DRIVING ON WILBETH RD., AKRON, OH AT A VERY SLOW RATE APPROX. 25 M.P.H. WHICH WAS THE SPEED LIMIT. I HIT A POTHOLE AND MY AIRBAG DEPLOYED AND I HAVE INJURIES DUE TO THAT ACCIDENT WHICH I WENT TO THE HOSPITAL AND WAS EXAMINED AND X-RAYED. I HAVE PICTURES OF THE AIRBAG AND THE POTHOLE I HIT. UNFORTUNATELY, THE STRE…
09/01/2004 · Airbags · crash
WHILE DRIVING CONSUMER'S VEHICLE WAS INVOLVED IN A COLLISION. IT HIT ANOTHER VEHICLE BROADSIDE, AND THE AIRBAG DEPLOYED. WHILE DEPLOYING STEERING WHEEL COVER CAME OFF AND HIT THE DRIVER IN THE STERNUM AND INJURED THE DRIVER.*AK
08/16/2004 · Fuel system
REQUEST FOR INFORMATION REGARDING THE FUEL SYSTEM ON 1991 CHRYSLER NEW YORKERS. *MR *SC *JB
08/12/2004 · Fuel system · fire
BLACK SMOKE AND LARGE FLAMES APPEARED FROM THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED AN INDEPENDENT MECHANIC, WHO INDICATED THE FUEL RAIL FAILED. *AK WHILE PARKED IN THE PARKING LOT WITH THE KEY STILL IN THE IGNITION SWITCH BUT WITH THE ENGINE TURNED OF, THE CONSUMER REALIZED THAT THE ENGINE WAS ON FIRE. THE FIRE…
04/05/2004 · Transmission / drivetrain
THE VEHICLES TRANSMISSION KEEPS BUCKLING AT HIGHWAY SPEED. THE DRIVER FEELS THIS IS VERY DANGEROUS. THE VEHICLE JERKS REALLY HARD. THE DEALER STATED THAT THE TRANSMISSION NEEDS TO BE REPLACED. PLEASE PROVIDE ANY FURTHER INFORMATION. *NM