1985 Ford Bronco Ii recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
What could happen: A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
The fix: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 BRONCO II.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 07E064000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequence: A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1985 Ford Bronco Ii owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (7), Transmission / drivetrain (3), Engine (3), Body / structure (2), Visibility (wipers / glass) (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/04/2003 · Transmission / drivetrain
THE FRONT SEAL ON THE A4LD AUTOMATIC TRANSMISSION IN MY 1985 BRONCO II FAILED. WHEN THIS HAPPENED THE TRANSMISSION FLUID BLEW BACK ACROSS THE EXHAUST PIPE CAUSING A LOT OF SMOKE. I HAVE DONE A LOT OF RESEARCH AND FIND THAT THIS IS A COMMON PROBLEM WITH THIS VEHICLE AND TRANSMISSION. *JB
10/28/1999 · Body / structure
THE FRAME CRACKED BY THE MOUNT OF THE SHOCK ABSORBER(REAR RIGHTSIDE)
05/09/1999 · Transmission / drivetrain
TRANSMISSION FAILED. YH
05/09/1999 · Engine
ENGINE FAILED.
05/03/1996 · Electrical system
IGNITION SWITCH FAILS INTERMITTENTLY. *DSH
04/30/1996 · Electrical system · fire
VEHICLE WAS PARKED AT UNIV. OF NM, DRIVER WAS AWAY FROM VEHICLE, SUDDENLY VEHICLE WAS ENGULFED IN FLAMES. *AK
04/30/1996 · Electrical system · fire
VEHICLE WAS PARKED AT UNIV. OF NM, DRIVER WAS AWAY FROM VEHICLE, SUDDENLY VEHICLE WAS ENGULFED IN FLAMES. *AK
04/24/1996 · Electrical system · fire
EXPERIENCED SHORT IN DASH WHICH CAUSED A FIRE. PLEASE GIVE MORE DETAILS. *AK