1989 Ford Bronco recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
What could happen: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
The fix: DEALERS WILL REPLACE THE IGNITION SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1989 BRONCO.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 96V071000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:IGNITION
Summary: THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Notes: SYSTEM: ELECTRICAL; IGNITION SWITCH. VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES AND LIGHT DUTY TRUCKS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. TIRE RESERVE LOAD LABEL MAY NOT HAVE BEEN INSTALLED.
What could happen: VEHICLE WOULD NOT COMPLY WITH FMVSS 110.
The fix: INSTALL PROPER LABEL.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1989 BRONCO.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 89V220000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: TIRE RESERVE LOAD LABEL MAY NOT HAVE BEEN INSTALLED.
Consequence: VEHICLE WOULD NOT COMPLY WITH FMVSS 110.
Remedy: INSTALL PROPER LABEL.
Notes: SYSTEM: TIRE RESERVE LOAD LABEL / FMVSS 110.VEHICLE DESCRIPTION: PASSENGER VEHICLE.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 1989 Ford Bronco owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (32), Engine (17), Brakes (11), Hydraulic (11), Fuel system (10).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/05/2010 · Steering
TL*THE CONTACT OWNS A 1989 FORD BRONCO. THE CONTACT WAS UNABLE TO START THE VEHICLE BECAUSE THE KEY WOULD NOT TURN IN THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER REPLACED THE IGNITION SWITCH UNDER NHTSA CAMPAIGN ID NUMBER 96V071000 (ELECTRICAL SYSTEM: IGNITION). THE DEALER WAS UNABLE TO START THE VEHICLE DUE TO A DEF…
06/02/2004 · Electrical system · fire
CONSUMER PARKED THE VEHICLE AT A RESTAURANT AND WENT INSIDE TO EAT. WITHIN TEN MINUTES THE CONSUMER NOTICED FIRE TRUCKS COMING INTO THE RESTAURANT'S PARKING LOT. CONSUMER WENT OUTSIDE TO INVESTIGATE WHAT WAS GOING ON, AND NOTICED THAT HIS VEHICLE WAS ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP, AND…
11/17/2003 · Body / structure
THE FLOOR PAN UNDERNEATH THE DRIVER'S SIDE SEAT HAD THROWN. IF VEHICLE WAS INVOLVED IN AN ACCIDENT OR BRAKES HAD TO BE DEPRESSED SUDDENLY DRIVER'S SIDE SEAT BELT WOULD RIP OUT BECAUSE IT WAS ATTACHED TO THE FLOOR PAN. THERE WAS TSB/ RECALL IN ALL DATA B93900801 FOR THE FLOOR PAN REINFORCEMENT(NOT IN ARTEMIS). ARTEMIS HAS INVESTIGATION PE90036, BUT IT'…
09/10/2002 · Electrical system · fire
VEHICLE HAD BEEN SITTING OVER NIGHT WHEN IT CAUGHT ON FIRE. FIRE DEPARTMENT STATED STEERING COLUMN AND DASH PLAYED A MAJOR PART IN FIRE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
05/05/2002 · Electrical system
WITH NO WARNING MY BRONCO DIED WHILE I WAS TRAVELING AT 45 MPH IN WORK TRAFFIC. I HAD TO PUSH THE BRONCO OUT OF TRAFFIC, AND THEN WAIT 2 HRS. FOR A TOW TRUCK TO TOW ME TO A MECHANIC, WITHA REPAIR BILL OF $184.00 TO REPLACE THE DEFECTIVE IGNITION MODULE. I WANT TO BE REIMBURSED $184.00. THIS SHOULD NOT HAVE FAILED - I COULD HAVE BEEN KILLED!!!!!*AK
03/22/2002 · Electrical system · fire
VEHICLE HESITATED AND SMOKE COMING FROM HOOD AREA. VEHICLE BURNED TO THE GROUND.*AK
03/14/2002 · Brakes
WHILE DRIVING WOULD STEP ON BRAKE PEDAL TO STOP OR TO REDUCE THE SPEED OF THE VEHICLE, BUT BRAKES WILL NOT ACTIVATE ON TIME. HAD CONTACTED DEALER. PLEASE PROVIDE MORE INFORMATION.*AK
03/14/2002 · Engine
WHILE DRIVING COULD HEAR A LOT OF NOISE. HAD CONTACTED DEALER, BUT THEY COULD NOT DETERMINE WHAT WAS CAUSING THE NOISE. PLEASE PROVIDE MORE INFORMATION. *AK