1994 Ford Crown Victoria recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Summary: IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.
Consequence: SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES.
Remedy: FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 18, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: VEHICLE SPEED CONTROL:CRUISE CONTROL
Summary: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 08S01. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Summary: THE NUTS AND BOLTS THAT ATTACH THE REAR BRAKE ADAPTOR TO THE AXLE HOUSING FLANGE CAN LOOSEN AND EVENTUALLY SEPARATE. IF ONE OR MORE OF THE NUTS COME OFF THE BOLTS, DAMAGE TO THE PARKING BRAKE ASSEMBLY OR TO THE ANTILOCK BRAKE SYSTEM (ABS) SENSOR AND SENSOR RING (IF SO EQUIPPED) WILL OCCUR. IF ALL FOUR NUTS ON ONE END OF THE AXLE COME OFF THE BOLTS, DAMAGE TO THE BRAKE HYDRAULIC LINE OR THE PARKING BRAKE CABLE CAN OCCUR.
Consequence: OCCURRENCE OF ANY OF THESE CONDITIONS CAN RESULT IN A LOSS OF BRAKING CAPABILITY AND POSSIBLE ACCIDENT.
Remedy: DEALERS WILL INSPECT AND, IF NEEDED, INSTALL NEW BOLTS. IF ANY OF THE FASTENERS ARE DISCONNECTED, THE PARKING BRAKE AND ABS COMPONENTS WILL BE INSPECTED AND SERVICED.
Notes: SYSTEM: BRAKES; HYDRAULIC SYSTEM. VEHICLE DESCRIPTION: PASSENGER CARS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT FORD SERVICE CENTER AT 1-800-392-3673. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Summary: VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.
Consequence: EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
Notes: OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 14, 1997. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
Summary: THE BOLTS THAT ATTACH THE FRONT UPPER CONTROL ARMS TO THE FRAME MOUNTING BRACKETS CAN LOOSEN AND FRACTURE AT ONE OF THE BOLT HOLES CAUSING SUBSTANTIAL NEGATIVE CAMBER AND STEERING PULL TO THE AFFECTED SIDE.
Consequence: IF THE DRIVER'S SIDE BRACKET FRACTURED AT BOTH BOLT HOLES, THE STEERING CONTROL ARM CAN CONTACT THE STEERING COLUMN SHAFT AND RESULT IN A LOSS OF STEERING CONTROL INCREASING THE POTENTIAL FOR AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TORQUE LEVELS OF THE FOUR UPPER CONTROL ARM MOUNTING BOLTS, AND IF ANY ARE LOOSE, THE BRACKETS WILL BE INSPECTED FOR DAMAGE. IF DAMAGE IS PRESENT, IT WILL BE REPAIRED.
Notes: SYSTEM: SUSPENSION; FRONT CONTROL ARM; UPPER. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A POLICE PACKAGE OPTION. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

03/09/2023 · Brakes
The contact owns a 1994 Ford Crown Victoria. The contact stated that while his brother was driving at an undisclosed speed, the brake pedal was depressed; however, the pedal became spongy. Additionally, the ABS warning light was illuminated. The contact inspected the vehicle and noticed a leak coming from the brake line. The contact related the failure to N…

04/03/2020 · Suspension
TL* THE CONTACT OWNS A 1994 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, IT BECAME DIFFICULT TO STEER THE VEHICLE. THE CONTACT STATED THAT THE FRONT SUSPENSION DETACHED AT THE BALL JOINT. THE FAILURE CAUSED THE BRAKE DUST COVER TO PUNCTURE THE TIRE. THE VEHICLE CAME TO AN ABRUPT STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDE…

01/07/2018 · Vehicle Speed Control · fire
AFTER DRIVING 30 MILES, I PARKED THE CAR IN THE DRIVEWAY AT MY HOME. APPROXIMATELY 10 MINUTES LATER, I WAS INFORMED THAT THE CAR WAS ON FIRE UNDER THE ENGINE HOOD. I ATTEMPTED TO UNLATCH THE HOOD BUT WAS UNABLE TO DUE TO THE UNLATCH CABLE BEING DESTROYED BY THE FIRE. THE FIRE HAD MELTED A BIG HOLE IN THE HOOD AT THE LEFT REAR CORNER AND HAD DESTROYED THE…

05/02/2017 · Vehicle Speed Control
HOLD LATCH BROKE A NUMBER OF DAYS AGO, ONE DAY DRIVING 60MPH ON THE HIGHWAY THE HOOD FLEW UP AND SMASHED MY WINDSHIELD. A FEW MONTHS LATER MY FUEL PUMP CAUGHT ON FIRE, I HAD NO IDEA UNTIL I GOT UNDER THE CAR BECAUSE IT DIDN'T WANT TO START. I'M GLAD TO BE ALIVE FROM THE FIRE, THE CAR COULD HAVE BLOWN UP! MY ABS BRAKE LIGHT IS ON AS WELL! LAST NIGHT I WAS RE…

11/13/2015 · Wheels / tires
TL* THE CONTACT OWNS A 1994 FORD CROWN VICTORIA EQUIPPED WITH MICHELIN LTX M/S TIRES, SIZE: P235/75R-15. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO VIBRATE. SUDDENLY, THE FRONT DRIVER SIDE TIRE EXPERIENCED A BLOW OUT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE DOT NU…

04/04/2014 · Vehicle Speed Control
TL* THE CONTACT OWNS A 1994 FORD CROWN VICTORIA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE ERRONEOUSLY ACCELERATED TO 85 MPH. THE VEHICLE FAILED TO SLOW DOWN WITH THE BRAKE PEDAL BEING ENGAGED. THE ENGINE WAS TURNED OFF AND THE VEHICLE CAME TO A STOP. AFTER RESTARTING, THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED FIVE MONTHS L…

11/16/2011 · Body / structure
TL* THE CONTACT OWNS A 1994 FORD CROWN VICTORIA. THE CONTACT WAS DRIVING 70 MPH WHEN THE HOOD POPPED OPEN, IMPAIRING THE CONTACT'S VISION OF THE ROADWAY AND SHATTERING THE FRONT WINDSHIELD. THE CONTACT WAS ABLE TO SAFELY PULL OVER TO THE SIDE OF THE ROAD AND ATTEMPTED TO CLOSE THE HOOD BUT THE LATCH WOULD NOT CATCH. THE CONTACT THEN SECURED THE HOOD CLOSE…

05/12/2011 · Lights
ON SEVERAL OCCASSIONS WHILE DRIVING MY 1994 FORD CROWN VICTORIA AT NIGHT, THE HEADLIGHTS ON MY VEHICLE HAVE WENT OUT LEAVING ME WITHOUT LIGHTS FOR SEVERAL MONENTS. I DO NOT KNOW THE REASON WHY THIS IS KEEPS OCCURRING. I HAVE BEEN TOLD BY OTHERS WITH SIMILAR YEAR MODEL FORD VEHICLES THAT THEY HAVE HAD SIMILAR PROBLEMS AND THAT THERE IS SUPPOSE TO BE A RECALL…