2002 Ford Escort recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.
What could happen: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.
The fix: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 ESCORT.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 04E048000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT
Summary: CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.
Consequence: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.
Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE.
THE RECALL BEGAN ON AUGUST 27, 2004.
Notes: THIS RECALL ONLY PERTAINS TO SERVICE REPLACEMENT EQUIPMENT FOR USE IN 1997-2003 MODEL YEAR FORD ESCORT AND MERCURY TRACER 4-DOOR AND STATION WAGON VEHICLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED IN FORD VEHICLES BY FORD MOTOR COMPANY.
FOR MORE INFORMATION CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2002 Ford Escort owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (20), Engine (16), Suspension (14), Brakes (7), Airbags (7).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
03/06/2017 · Vehicle Speed Control · crash
TL* THE CONTACT OWNED A 2002 FORD ESCORT. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT'S VEHICLE REAR ENDED ANOTHER VEHICLE. THE DRIVER OF THE CONTACT'S VEHICLE AND FOUR OCCUPANTS IN THE OTHER VEHICLE WERE INJURED. MEDICAL ATTENTION WAS RECEIVED. A POLICE REPORT WAS FILED. THE AIR BAGS DEPLOYED ON IMPACT. PRIOR TO THE CRASH, THE VEHICLE ACCELERATED WHILE…
11/17/2011 · Engine
2002 FORD ESCORT. CONSUMER WRITES IN REGARDS TO VEHICLE STOPPING AND DYING WHILE DRIVING *TGW THE CONSUMER STATED THE BATTERY AND ALTERNATOR WERE REPLACE THREE TIMES, AS WELL AS OTHER COMPONENTS. HOWEVER, THE STALLING CONTINUED. NO ONE HAS BEEN ABLE TO DETERMINE THE REASON FOR THE STALLING. *JB
08/03/2010 · Suspension
2002 FORD WINDSTAR REAR AXLE PROBLEM WE WERE DRIVING ON 78E AND WERE APPROXIMATELY 30 MINUTES BEFORE ALLENTOWN. ALL OF A SUDDEN WE HEARD A CRACK, SMELLED SMOKE, AND HEARD METAL SCRAPING. THE CAR STARTED FISHTAILING AND MY HUSBAND VIRTUALLY HAD NO CONTROL OF THE CAR AS THE WINDSTAR REPEATEDLY CROSSED 2 LANES AND ALMOST HIT THE MIDDLE BARRIER AND THEN FIS…
03/30/2010 · Transmission / drivetrain
WE BOUGHT A NEW 2002 ZX2, ONE MONTH AFTER WE HAD IT THE TRANSMISSION STARTED SLIPPING. NOW THE TRANSMISSION WON'T SHIFT INTO 3RD OR 4TH. WE WERE TOLD WE NEED TO REBUILD OURS.
11/16/2009 · Transmission / drivetrain
RE: 2002, FORD ZX2 WE OWN A 2002 STANDARD MODEL FORD ZX2 THAT HAS ONLY 35,500 MILES ON IT. THERE ARE THREE NOTABLE PROBLEMS: 1.THE ENGINE IDLES VERY ROUGHLY 2.THE TRANSMISSION SHIFTS VERY HARD 3.THE FRONT DRIVER DOOR HAS SAGGED AND WON?T CLOSE COMPLETELY. ALL OF THESE ISSUES ARE THE RESULT OF POOR DESIGN AND ESPECIALLY POOR QUALITY PARTS. THIS CA…
07/31/2009 · Brakes
TL*THE CONTACT OWNS A 2002 FORD ESCORT. WHENEVER THE BRAKES WERE APPLIED, THE CONTACT WOULD HEAR A GRINDING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE FRONT ROTORS AND PADS. THE CURRENT AND FAILURE MILEAGES WERE 7,367.
05/22/2009 · Brakes
ABS AND BRAKE LIGHTS HAS CONTINUED TO BE ON AND CRUISE CONTROL HAS STOPPED WORKING. *TR
04/26/2009 · Steering
WE HAVE A 2002 ESCORT ZX2 . THE CAR WAS BOUGHT FEBRUARY 2002 . I HAVE HAD SOME REAL PROBLEMS WITH THE TIE -RODS HAVING TO BE REPLACED. BUT THE PROBLEM NOW IS THE WIRING TO THE TAIL LIGHTS. WE HAVE HAD A FEW PROBLEMS WITH THE FUSE BLOWING AND WE REPLACE IT , THEN THE LIGHT BULBS BLOW THEN WE REPLACE THEM . WE HAD A MECHANIC LOOK INTO THE PROBLEM THIS TIME…