1997 Ford F-350 recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: TIRES:TREAD/BELT
Summary: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Consequence: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Notes:

Component: TIRES:BEAD
Summary: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND CHASSIS. THE TIRES ON THESE VEHICLES WERE DAMAGED DURING MOUNTING ONTO THE WHEELS. ONLY TRUCKS PRODUCED AT THE CUAUTITLAN, MEXICO PLANT BETWEEN SEPTEMBER 1, 1996, AND JULY 17, 1997, WERE AFFECTED BY THE DEFECT.
Consequence: THE BEAD AREA OF THE TIRE WAS CUT WHICH COULD RESULT IN AIR LOSS. SUDDEN AIR LOSS COULD OCCUR RESULTING IN A LOSS OF VEHICLE CONTROL.
Remedy: DUE TO THE AGE OF THE VEHICLES AND THIS RECALL AFFECTING ORIGINAL EQUIPMENT TIRES ONLY, FORD WILL NO LONGER ACCEPT CLAIMS FOR THIS CAMPAIGN.
Notes: FORD RECALL NO. 97S90. OWNER NOTIFICATION BEGAN DECEMBER 1, 1997. OWNERS WHO TAKE THEIR VEHICLES TO A FIRESTONE DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FIRESTONE AT 1-800-457-6281. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Summary: THE RETAINER CLIP THAT HOLDS THE MASTER CYLINDER PUSH ROD TO THE BRAKE PEDAL ARM IS MISSING.
Consequence: A LOSS OF SERVICE BRAKING CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT TO VERIFY THAT THE RETAINER CLIPS ARE INSTALLED AND IF CLIPS ARE MISSING WILL INSTALL CLIPS.
Notes: OWNER NOTIFICATION: OWNER NOTIFICATION OCCURRED SEPTEMBER 30, 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

10/24/2019 · Transmission / drivetrain
ON THE PASSENGER SIDE OF THE ENGINE PAN THE DIPSTICK ADAPTER WAS MANUFACTURED POORLY. THE OIL FROM THE CRANKCASE HAS CAUSED THE ORING TO SWELL AND LEAK OIL. THE OIL LEAK IS GETTING ON THE STARTER AND CLUTCH. THE OIL CAN CAUSE A SHORT IN THE ELECTRICAL SYSTEM. THIS CAN CAUSE AN ACCIDENT OR DEATH WHILE DRIVING. THE OIL ON THE CLUTCH CAN CAUSE LOSS OF CONTROL…

08/08/2017 · Engine
TL* THE CONTACT OWNS A 1997 FORD F-350. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND IT STALLED A SECOND TIME. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE HOME. GLADIAN REPAIR SHOP OF PITTSBURG, VIRGINIA WAS MADE AWARE OF THE FAILURE AND SUGGESTED A LIST OF UNKNOWN REPAIRS. CAMEL BROTHERS REPAIR…

04/21/2015 · Engine
TL* THE CONTACT OWNS A 1997 FORD F-350. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE CONTACT INDICATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CAM SHAFT POSITION SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAI…

04/15/2015 · Wheels / tires
WE WERE TRAVELLING 65 MPH ON THE 91 FREEWAY TOLL ROAD WHEN MY LEFT REAR TIRE TREAD COMPLETELY SEPARATED FROM THE CASING CAUSING MY VEHICLE TO SWERVE AND JUMP AND CAUSING SIGNIFICANT DAMAGE TO MY VEHICLE, INCLUDING DAMAGING THE FUEL FILL LINE. FORTUNATELY THERE WAS NO FUEL LEAKAGE. THE TIRE DID NOT DEFLATE SO THERE WAS NO PUNCTURE OR OTHER EXTERNALLY CAUSED…

05/05/2014 · Engine · fire
WHILE DRIVING MY 1997 FORD F350 DIESEL PICKUP, PULLING A 36FT GOOSENECK HORSE TRAILER WITH MY TWO TEENAGE DAUGHTERS AND THEIR FOUR HORSES, THE ENGINE IN MY PICKUP SPONTANEOUSLY IGNITED. THERE WAS NO "CHECK ENGINE" WARNING LIGHT, AND THE ENGINE TEMPERATURE GAUGE SHOWED NORMAL. THE ONLY WARNING I HAD WAS SMOKE COMING UP FROM THE LEFT WHEEL WELL UPON SPEED D…

06/04/2013 · Body / structure
TL* THE CONTACT OWNS 1997 FORD F-350. THE CONTACT STATED THAT SHE NOTICED THAT THE FRAME WAS FRACTURED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000. *TR

10/01/2011 · Wheels / tires · crash
REAR DRIVER SIDE TREAD SEPARATED FROM TIRE AT 75MPH IN THE STATE OF NEBRASKA.22HRS. LATER IN THE STATE OF OHIO THE PASSENGER REAR SEPARATED. CONTACTED FIRESTONE AND THEY WILL NOT TAKE ANY RESPONSIBILITY FOR INCIDENT. *TR

08/08/2011 · Fuel system
TL* THE CONTACT OWNS A 1997 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE FUEL GAUGE METER SUDDENLY INDICATED THAT THE FUEL TANK WAS EMPTY. THE CONTACT ALSO DISCOVERED THAT THE PANEL FOR THE FUEL TANK WAS DETACHED, CAUSING THE FUEL TANK TO BE SEPARATED FROM THE CHASSIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE MANUFACTURER WAS N…