2003 Ford Navigator recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Engine (3), Steering (1), Seat belts (1), Suspension (1), Airbags (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (5)
09/23/2007 · Engine
03 NAVIGATOR BEGAN "STUTTERING" WHEN DRIVING, FELT LIKE A TRANSMISSION SLIPPING. I TOOK IT TO THE DEALER AND THEY SAID THREE OF THE EIGHT CYLINDERS WERE NOT AT FULL COMPRESSION. HE ADVISED NEW HEADS WERE NEEDED. COST: $7000. SEVERAL SERVICE BULLETINS HAVE BEEN ISSUED ON THE PROBLEM, INDEPENDENT (FORMER FORD TECH) MECHANIC LOOKED AT THE PROBLEM. HE ADVI…
01/26/2007 · Steering
TL* - THE CONTACT OWNS A 2001 LINCOLN NAVIGATOR. ON 3 DIFFERENT OCCASIONS THE SPARK PLUGS EXPLODED, AND SHE HAS HAD TO REPLACE THE SPARK PLUGS AND COILS. THE CONTACT STATED THAT WHEN THE SPARK PLUGS EXPLODED THEY SENT SENDS THE FRAGMENTS FROM THE SPARK PLUGS INTO THE ENGINE. EACH TIME THIS HAPPENED THE NUMBER 3 AND NUMBER 4 SPARKS WERETHE ONES THAT E…
11/09/2006 · Engine
2003 FORD EXPEDITION XLT WITH 5.4 LITER TRITON V8 ENGINE WITH 59,000 MILES. THE VEHICLE IS WELL MAINTAINED AND NOT ABUSED. THE #3 SPARK PLUG WAS BLOWN OUT OF THE ALUMINUM CYLINDER HEAD DURING DRIVING AT APPROXIMATELY 5 MPH. THIS EVENT WAS PRECEDED BY A TAPPING NOISE WHICH OCCURRED OVER THE PRECEDING TWO WEEKS. THE NOISE WAS SIMILAR TO A NOISY VALVE LIFT…
03/28/2005 · Suspension
ON FEBRUARY 25, 2005, I TOOK MY 2003 LINCOLN NAVIGATOR TO THE SERVICE DEPARTMENT FOR A MAJOR FRONT AIR SUSPENSION PROBLEM; THE FRONT HALF OF MY CAR WAS SO LOW TO THE GROUND WHILE THE BACK HALF WAS SET HIGH. THE RIDE WAS VERY BUMPY, ROUGH,AND UNWIELDY . THE DEALERSHIPS SERVICE PERSONNEL DETERMINED THE VEHICLE'S AIR SUSPENSION COMPRESSOR WAS INOPERABLE AND TH…
01/08/2003 · Airbags
CONSUMER STATES THAT VEHICLE'S FRONT PASSENGER SIDE AIRBAGS SENSOR STAYS ON. DEALER NOTIFIED. PLEASE PROVIDE ADDITIONAL INFORMATION. TS