1985 Ford Ranger recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
What could happen: A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
The fix: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 RANGER.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 07E064000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Consequence: A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
What could happen: LOSS OF BRAKING CAN RESULT.
The fix: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 RANGER.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 98E010000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, AIR:DISC:ROTOR
Summary: EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
Consequence: LOSS OF BRAKING CAN RESULT.
Remedy: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING APRIL 1998. OWNERS WHO DO NOT RECEIVE THE FREE ROTORS WITHIN A REASONABLE TIME SHOULD CONTACT AIMCO AT 815-759-7935. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. THE NYLON FUEL SUPPLY AND RETURN LINES ARE IMPROPERLY ROUTED ALONG THE FRAME SIDE RAIL AND COULD CONTACT THE UNIVERSAL JOINT ON THE FRONT DRIVESHAFT. CONSEQUENCE OF DEFECT: SUCH CONTACT COULD CAUSE ABRASION OF THE LINES AND LOW PRESSURE FUEL LEAKAGE CREATING THE POTENTIAL FOR A FIRE.
What could happen:
The fix: REROUTE OR REPLACE AFFECTED FUEL LINES.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1985 RANGER.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 85V045000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: THE NYLON FUEL SUPPLY AND RETURN LINES ARE IMPROPERLY ROUTED ALONG THE FRAME SIDE RAIL AND COULD CONTACT THE UNIVERSAL JOINT ON THE FRONT DRIVESHAFT. CONSEQUENCE OF DEFECT: SUCH CONTACT COULD CAUSE ABRASION OF THE LINES AND LOW PRESSURE FUEL LEAKAGE CREATING THE POTENTIAL FOR A FIRE.
Consequence:
Remedy: REROUTE OR REPLACE AFFECTED FUEL LINES.
Notes: VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH 2.3 LITER ENGINES AND ELECTRONIC FUEL INJECTION SYSTEMS. SYSTEM: FUEL LINES.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1985 Ford Ranger owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (14), Transmission / drivetrain (5), Visibility (wipers / glass) (4), Engine (3), Fuel system (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
03/16/2007 · Engine
STALLS AT ANY TEMPERATURE WHILE DRIVING. WHEN STOPPED I HAVE TO ALMOST FLOOR THE GAS PEDAL TO GET MOVING W/O STALLING. HEATER GETS ALMOST TOO HOT.
03/20/2002 · Electrical system
VEHICLE WILL SHUT OFF WHILE CONSUMER WAS DRIVING. CONTACTED DEALER, AND DEALER STATED THAT VEHICLE WAS CUTTING OFF BECAUSE IGNITION MALFUNCTIONED. *AK
02/11/2002 · Fuel system
VEHICLE STALLS AT ALL SPEEDS, IT APPEARS TO BE A MODULE ON DISTRIBUTOR, PLACED NEAR ENGINE BLOCK. ALSO HAD PROBLEM WITH SPEEDOMETER CABLE.
09/05/2001 · Transmission / drivetrain
THE VEHICLE LOST IT'S U JOINT WHICH CAUSED THE DRIVE SHAFT TO BREAK DAMAGING THE FUEL TANK AND DISABLED THE VEHICLE.(OHIO TRAFFIC CRASH REPORT) *YH
05/08/2001 · Electrical system
IGNITION SWITCH HAS FAILED TWICE. ONCE AT 80,000,AND AGAIN AT 200,000 MILES. CAUSE UNKNOWN. PLEASE PROVIDE FURTHER INFORMATION.*AK
02/08/2001 · Electrical system
WHILE DRIVING VEHICLE JUST STALLED WHITHOUT A PRIOR WARNING. CONSUMER WAS CRANKING ENGINE, BUT IT DID NOT START. CONSUMER REPLACED IGNITION MODULE. THEN,COULD START VEHICLE WITHOUT A PROBLEM.*AK
02/01/2001 · Visibility (wipers / glass)
STREAM AND LIQUID CAME OUT OF HEATER SYSTEM, BURNED DRIVER'S LEG AND FOOT, CAN NOT USE HEATER. *CJ
10/12/2000 · Electrical system
WHILE TRAVELING AND WITHOUT ANY INDICATION VEHICLE WOULD STALL. PLEASE PLROVIED FURTHER INFORMATION.*AK