1992 Ford Thunderbird recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
What could happen: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 09E012000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-909-598-7589.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
2. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
What could happen: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 99V275000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
Notes: FORD RECALL NO. 99S30. OWNER NOTIFICATION BEGAN NOVEMBER 15, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE…
What could happen: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
The fix: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 97V159000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 27, 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
What could happen: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
The fix: DEALERS WILL REPLACE THE IGNITION SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 THUNDERBIRD.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 96V071000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:IGNITION
Summary: THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Notes: SYSTEM: ELECTRICAL; IGNITION SWITCH. VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES AND LIGHT DUTY TRUCKS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 1992 Ford Thunderbird owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Lights (44), Brakes (35), Hydraulic (30), Electrical system (28), Fuel system (27).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/02/2012 · Brakes
THE REAR BRAKES FAILED TO FUNCTION AND NO POWER BRAKES AT ALL REALLY HARD PEDAL HAD TO STAND ON THE BRAKE PEDAL TO GET IT TO STOP THIS HAPPENED UNDER NORMAL DRIVING CONDITIONS THIS MAKES IT VERY HARD TO STOP I WAS ABLE TO GET IT OFF THE ROAD CALLED A TOW TRUCK AND HAD IT TOWED TO MY HOUSE FORD.COM SAID NO RECALLS FOR MY CAR AND IT COST $1500 TO FIX . *TR
09/15/2010 · Electrical system
1992 FORD THUNDERBIRD RECALLED FOR REPLACEMENT OF IGNITION SWITCH A FEW YEARS BACK (NHTSA ACTION NUMBER: EA95002). DEFECTIVE SWITCH WAS REPLACED WITH EXACT SAME PART THAT WAS RECALLED AND FAILED AGAIN WITHIN ONE YEAR WITH TWO HALVES OF UNIT AGAIN COMING APART. I HAVE JUST REPLACED FOR THE FIFTH TIME WITH EXACT SAME DEFECTIVE UNIT, THIS BEING THE ONLY THIN…
10/21/2008 · Seat belts
I GOT INTO MY CAR THIS MORNING AND THE DRIVER POWER SEAT BELT WOULD NOT WORK. WHEN I OPENED THE DOOR TO MY PASSENGER SIDE THE POWER SEAT BELT ON THE DRIVER SIDE ATTEMPTED TO WORK BUT DIDN'T WORK COMPLETELY. THERE WAS NO EVENTS LEADING TO THE FAILURE. THIS ISN'T SOMETHING THAT HAS HAPPENED BEFORE. I HAVEN'T MADE AN ATTEMPT TO GET IT FIXED YET AS IT JUST HAP…
10/04/2007 · Lights
TL*THE CONTACT OWNS A 1992 FORD THUNDERBIRD. IN APRIL OF 2000, THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE HEADLIGHTS. THE RECALL REPAIR WAS NOT PERFORMED AT THAT TIME BECAUSE THERE WERE NO FAILURES WITH THE VEHICLE. CURRENTLY, THE HEADLIGHTS AND FOG LIGHTS FLICKER ON AND OFF AND TWO PARTS NEED TO BE REPLACED. SHE TOOK THE VEHICLE TO THE DEALER A…
02/15/2005 · Seat belts
THE AUTOMATIC SEAT BELTS DON'T WORK. ON THE DRIVER'S SIDE, THE SEAT BELT STAYS IN A POSITION THAT APPEARS TO BE EFFECTIVE, BUT IT DOES NOT GO ALL THE WAY BACK. IT ALSO NO LONGER MOVES FORWARD WHEN THE DOOR IS OPENED. ON THE PASSENGER SIDE, THE SEAT BELT WORKS MOST OF THE TIME. HOWEVER, IT OCCASIONALLY GETS STUCK IN A POSITION WHERE IT HAS MOVED FORWARD…
01/24/2005 · Electrical system
CONSUMER' S VEHICLE EXPERIENCED THE SAME PROBLEMS AS STATED IN NHTSA RECALLS 96V071000 AND 99V27500 CONCERNING IGNITION SYSTEM AND HEADLIGHTS. THE DEALERSHIP INDICATED CONSUMER'S VEHICLE NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *NM
08/24/2004 · Electrical system · fire
WHILE DRIVING CONSUMER SMELLED SMOKE COMING IN FROM THE VENTS. CONSUMER PULLED OVER, LIFTED THE HOOD UP, AND VEHICLE CAUGHT ON FIRE. CONSUMER WAS ABLE TO EXTINGUISH THE FIRE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. *AK
08/13/2004 · Electrical system
WHILE PLACING THE KEY INSIDE OF THE IGNITION SWITCH THE KEY FAILED TO COME OUT FROM THE IGNITION. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. *AK