2003 GMC Envoy Xl recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
What could happen: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
The fix: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 ENVOY XL.
- Book a repair at any authorized GMC dealer. Quote NHTSA campaign 04V527000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:BRAKE LIGHTS
Summary: ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR
GMC AT 1-866-996-9463.
Notes: GM RECALL NO. 04087. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
What could happen: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
The fix: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSM…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 ENVOY XL.
- Book a repair at any authorized GMC dealer. Quote NHTSA campaign 04V046000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
Summary: CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Notes: GM RECALL NO. 04005. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RH…
What could happen: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
The fix: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLE…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 ENVOY XL.
- Book a repair at any authorized GMC dealer. Quote NHTSA campaign 05V494000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-630-2438.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Notes: GM RECALL NO. 05077. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2003 GMC Envoy Xl owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (165), Electrical system (136), Gasoline (116), Visibility (wipers / glass) (70), Body / structure (56).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/13/2026 · Fuel system
I can not put gas in my car. M garage smells of gas fumes. Very dangerous situation of possible fire or illness due to fumes ans I have no transportation. When I bought this car from GMC it had the sam problem. no recall just a safety bulletin. Manufacturer fixed it.There were no warning lights.
07/27/2026 · Visibility (wipers / glass)
My windshield wipers come on when you start the car, or when you just click the switch to put windows up, but the wiper switch is off. The wipers stay operating from 5 to 10 minutes before they shut off, and I am concerned the windshield and/or wipers may become damaged. This issue has just started to occur within the last week. There have been no warning m…
03/12/2026 · Electrical system
The contact owns a 2003 GMC Envoy. The contact stated that while in drive(D), the vehicle shut off and then restarted. The message “Service Engine Soon” was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined that the instrument cluster needed to be replaced. The vehicle was repaired, but the failure reoccurred. The v…
02/02/2026 · Suspension
The contact owns a 2003 GMC Envoy. The contact stated that while the vehicle was parked on several occasions, there was condensation under the front of the vehicle. The vehicle was taken to a dealer on several occasions, where it was determined that the differential needed to be repaired due to a leak coming from the axle. On several occasions, it was deter…
07/06/2025 · Unknown Or Other
Fuel indicator bounces from Empty to full in the matter of seconds while going down the road. Also, issues with mileage range reported as the fuel indicator is fluctuating.
07/06/2025 · Electrical system
The car's gas gauge and fuel range indicator are problematic. The fuel gauge quickly drops from a higher reading, like 3/4 full, to empty. After this, the gauge and the fuel range both fluctuate while driving, making it impossible to determine the fuel level.
09/19/2024 · Body / structure
I bought a 2003 GMC Envoy 3/23/24. The main frame and sub-frame have extensive rot, and is unsafe to drive. It is available to inspect. They disguised frame damage and sold me an unsafe vehicle. I brought the car in to have the ac repaired in August 2024 and when they put it up on the lift that's when they saw the damage. This was Rogers Automotive in West…
05/27/2024 · Lights
ISSUE: Hazard Warning/Turn Signal Flasher Module Failure. DESCRIPTION: Right front and rear turn signal and right front and rear hazard warning not working outside or inside vehicle. Replaced burned out right front turn signal/hazard. Replaced right rear turn signal/hazard due to corrosion on base of bulb. Looked at fixtures when replacing and all appeared…