2012 Harley-Davidson Flhtc recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. SEE THE ABOVE LIST FOR THE MODELS INCLUDED IN THE RECALL. THE REAR BRAKE LIGHT SWITCH MAY BE EXPOSED TO EXCESSIVE HEAT FROM THE EXHAUST SYSTEM.
What could happen: THE EXCESSIVE HEAT MAY CAUSE THE SWITCH TO NOT ACTIVATE THE BRAKE LAMP OR ACTIVATE THE BRAKE LAMP WHEN NO BRAKE IS APPLIED AND/OR CAUSE A BRAKE FLUID LEAK AT THE BRAKE LIGHT SWITCH, AFFECTING REAR BRAKE PERFORMANCE. EITHER CONDITION MAY INCREASE THE RISK OF A CRASH.
The fix: HARLEY-DAVIDSON WILL NOTIFY OWNERS, AND DEALERS WILL A INSTALL A REAR BRAKE LIGHT SWITCH KIT, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 31, 2011. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 FLHTC.
- Book a repair at any authorized Harley-Davidson dealer. Quote NHTSA campaign 11V506000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-414-343-4056.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009-2012 TOURING, CVO TOURING AND TRIKE VEHICLES MANUFACTURED FROM JUNE 6, 2008, THROUGH SEPTEMBER 16, 2011. SEE THE ABOVE LIST FOR THE MODELS INCLUDED IN THE RECALL. THE REAR BRAKE LIGHT SWITCH MAY BE EXPOSED TO EXCESSIVE HEAT FROM THE EXHAUST SYSTEM.
Consequence: THE EXCESSIVE HEAT MAY CAUSE THE SWITCH TO NOT ACTIVATE THE BRAKE LAMP OR ACTIVATE THE BRAKE LAMP WHEN NO BRAKE IS APPLIED AND/OR CAUSE A BRAKE FLUID LEAK AT THE BRAKE LIGHT SWITCH, AFFECTING REAR BRAKE PERFORMANCE. EITHER CONDITION MAY INCREASE THE RISK OF A CRASH.
Remedy: HARLEY-DAVIDSON WILL NOTIFY OWNERS, AND DEALERS WILL A INSTALL A REAR BRAKE LIGHT SWITCH KIT, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 31, 2011. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Notes: HARLEY-DAVIDSON SAFETY RECALL NUMBER IS 0145. CUSTOMERS OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- 2012 Harley-Davidson Flhtc owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Vehicle Speed Control (2), Electrical system (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (2)
04/10/2014 · Electrical system
WHILE IN TRAFFIC ON A BUSY ROAD THE MOTORCYCLE LOST ALL THROTTLE RESPONSE AND WENT INTO "LIMP MODE". DURING THIS TIME THE ENGINE RPM'S IMMEDIATELY DROPPED AND I WAS FORCED TO CROSS TWO LANES OF TRAFFIC AT MOVING AT HIGHWAY SPEEDS TO SAFELY PULL THE MOTORCYCLE TO A STOP. I WAS ONLY ABLE TO ACHIEVE A TOP SPEED OF 15 MPH. THE MOTORCYCLE WAS THEN TRANSPORTED…
08/20/2013 · Vehicle Speed Control · crash
I WAS LEAVING WORK ON SATURDAY ABOUT 4:15 WITH MY MOTORCYCLE. I WAS APPROACHING THE AREA WHERE I TURN TO GO IN FRONT OF THE BUILDING TO EXIT OUT TO THE ROAD. AS I WAS BRAKING, ABOUT TO TURN, THE BIKE ACCELERATED CAUSING THE REAR WHEEL TO LOSE TRACTION AND THE BIKE WENT DOWN. WHEN THE BIKE WENT DOWN, I WAS SLAMMED TO THE GROUND AND WAS SEPARATED FROM THE BIK…