2016 Harley-Davidson Flhtk recalls & complaints

Component: POWER TRAIN:CLUTCH ASSEMBLY
Summary: Harley-Davidson Motor Company (Harley-Davidson) is recalling certain model year 2016 Electric Glide Ultra Classic (FLHTCU), Electra Glide Ultra Classic Low (FLHTCUL), Ultra Limited Low (FLHTKL), Ultra Limited (FLHTK), CVO Street Glide (FLHXSE), Street Glide (FLHX), Street Glide Special (FLHXS), Road Glide Special (FLTRXS), Road Glide (FLTRX), Police Electra Glide (FLHTP), Road Glide Ultra (FLTRU), Fat Boy S (FLSTFBS), Softail Slim S (FLSS), and CVO Softail Pro Street Breakout (FXSE) motorcycles. In the affected motorcycles, the clutch master cylinder may lose the ability to generate enough lift to disengage the clutch, especially if the motorcycle has been parked for an extended period of time.
Consequence: When the engine is running and the motorcycle is in gear, if the clutch cannot be fully disengaged, the motorcycle may move unexpectedly, increasing the risk of a crash.
Remedy: Harley-Davidson will notify owners, and dealers will inspect the clutch master cylinder for the presence of gas in the fluid, if so, the dealer will flush the clutch system and rebuild the clutch master cylinder, free of charge. The recall began July 19, 2016. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0169.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

09/27/2023 · Wheels / tires
The Dunlop back tire cracked in center while less than half worn. Thread depth new is 8/32 inch and tire check 5/32 inch.

03/03/2023 · Unknown Or Other
The coolant pump failed causing the engine to over heat which I was informed is a known issue with this year model. Plus my ABS system failed which makes the bike unable to operate.

07/15/2020 · Unknown Or Other
WE WERE ON A MAJOR HIGHWAY GOING APPROXIMATELY 70 MPH WHEN THE BRAKES INSTANTLY LOCKED UP. WE WENT FROM 70 TO 0 IN SECONDS. WE BARELY MADE IT TO THE SHOULDER AS WE NEEDED TO CLEAR OTHER BIKES. PEOPLE BEHIND US CLAIM THE BRAKE LIGHTS NEVER CAME ON NOR DID THE ABS LIGHT TO INDICATE AN ISSUE. THE BRAKES REMAINED LOCKED FOR SEVERAL MINUTES BEFORE WE COULD E…

04/22/2020 · Brakes
ABS FAILURE, NO ABS FAILURE LIGHT ON. RIDING ON I82 BETWEEN KENNEWICK WA AND UMATILLA OR. RIDING AT 70 MPH, ATTEMPTED TO BRAKE FOR SLOW MOVING TRAFFIC AND DISCOVERED REAR BRAKE PEDAL IN HYDRAULIC LOCK CONDITION, UNABLE TO PUSH PEDAL DOWN...SO NO REAR BRAKE. ALMOST HAD AN ACCIDENT. WAS ABLE TO GET HARLEY HOME SAFELY. NHTSA CAMPAIGN NUMBER: 18V076000 EX…

10/16/2019 · Wheels / tires
LAST YEAR AT APROX 20K MILES ON A LONG STRETCH OF HIGHWAY THE FRONT WHEEL BEARINGS FAILED AND ALMOST LOST CONTROL OF THE MOTORCYCLE, HAD TO HAVE IT HAULED IN ON WRECKER TO GET FIXED UNDER WARRANTY AND THEY DID NOT PAY FOR THAT , WELL HERE IT IS APROX 13K MILES SINCE THEN AND IT HAS HAPPENED AGAIN

09/16/2019 · Vehicle Speed Control
TL* THE CONTACT OWNS A 2016 HARLEY-DAVIDSON FLHTK LIMITED. WHILE DRIVING WITH THE CRUISE CONTROL ACTIVATED, IT DISENGAGED AUTOMATICALLY WHEN GOING OVER BUMPS IN THE ROAD. ALSO, THE THROTTLE WOULD DECREASE AND THE VEHICLE LOST POWER. ON JULY 30, 2019, WHILE PULLING OUT OF A PARKING LOT, THE THROTTLE COMPLETELY FAILED IN TRAFFIC. THE CONTACT HAD TO ROLL THE V…

06/21/2019 · Wheels / tires
THE FRONT WHEEL WHERE THE TIRE SEALS AGAINST THE WHEEL THAT MATERIAL IN THAT AREA IS SEPARATING CAUSING THE TIRE TO GO FLAT. THE CONSUMER STATED THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE ROAD HAZARD WARRANTY HAD EXPIRED. *JS

02/22/2019 · Brakes
WHILE TRAVELING BETWEEN LA AND TEXAS ON IH10 WEST I APPLIED REAR BRAKES,DUE TOO RIDING IN A RAIN STORM ,WHERE AS THERE WAS NO PEDAL WENT TO FOOT BOARD ,APPLIED FRONT BRAKES AND SLOWED BIKE(ALMOST HIT THE TRUCK IN FRONT OF ME),TRIED REAR BRAKES AND HAD A PEDAL SO CONTINUED ON,LATER I SMELT SOMETHING BURNING SO I GOT OFF HIGHWAY TO CHECK, GOT SMOKE FROM MY R…