2020 Honda Crf1100d4 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (11), Engine (3), Vehicle Speed Control (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/17/2026 · Engine
The CRF1100 2020 DCT stalls when trying to take off form a complete stop. It happens most often at traffic lights and has already lead to dangerous situations with cars behind you expecting you to go but you stall. This bike is not supposed to stall and since it only happens on occasion (so far perhaps around 20 times), yesterday's ride it happened 3 times.…
01/22/2021 · Vehicle Speed Control · crash
WHEN GARAGING, I HAVE TO ROLL BACK AND MOVE FORWARD TO SQUARE OFF. BEING AN AUTOMATIC, YOU HIT A SWITCH TO CHANGE N TO D. I HIT N, ROLLED BACK, HIT D AND RELEASED THE BRAKE. THE BIKE SHOT FORWARD WITH NO THROTTLE INPUT 10 - 15 FT HITTING A ROCK WALL AND THROWING ME AGAINST MY CAR PINNING ME. NO ONE HEARD ME HOLLER FOR HELP. I HELD THE BRAKE WHILE REACHING O…
11/28/2020 · Engine
ON MULTIPLE OCCASIONS, THE ENGINE CUT OUT. SEVERAL TIMES WHILE I OPEN THE THROTTLE ALL THE WAY QUICKLY TO PASS ON A TWO LANE HIGHWAY. SEVERAL TIMES WHEN I'M CRUISING DOWN THE HIGHWAY AT 70 MPH, IT JUST STARTED MISSING. VERY DANGEROUS WHEN YOUR SPEED GOES FROM 70 TO 40 IN SECONDS ON THE FREEWAY.
08/30/2020 · Fuel system
VEHICLE WAS IN MOTION ON AN INTERSTATE HIGHWAY AT APPROXIMATELY 70 MILES AN HOUR, IN TRAFFIC, WHEN ENGINE SUDDENLY STOPPED RECEIVING ADEQUATE FUEL. REVS WERE LIMITED TO 4K AND INCOMING TRAFFIC BEHIND ME NEARLY CAUSED A COLLISION, DUE TO MY SUDDEN LOSS OF SPEED WITHOUT BRAKE LIGHTS. UPON TAKING TO SHOP, A WHITE PASTE-LIKE SUBSTANCE WAS FOUND COVERING SOME…
08/30/2020 · Fuel system
IMPROPER FUEL TANK WELDS PLUGGED THE FUEL FILTER WITH DEBRIS. DISCOVERED THE ZINC FLAKES UPON INSPECTION OF THE FUEL TANK. 425 MILES ON THE MOTORCYCLE AND LESS THAN 10 GALLONS OF GAS THROUGH THE TANK. UNLIKE AUTOMOBILES, WHEN A MOTORCYCLE FUEL SYSTEM IS COMPROMISED, A LOSS OF POWER CAN BE CATASTROPHIC TO THE RIDER. UNWILLING TO RISK MY SAFETY, INCLUDING DE…
08/06/2020 · Fuel system
THERE IS A CORROSION OR SOME OTHER TYPE OF DETERIORATION OF THE FUEL TANK WELDS INSIDE THE TANK THAT CAUSE A PARTICLE BUILD UP THAT CLOGS THE FUEL PUMP AND CAUSES THE VEHICLE TO LOSE POWER AND STALL. THE POWER LOSS HAPPENS PERIODICALLY. HONDA HAS FLUSHED THE FUEL TANK AND REPLACED THE FUEL PUMP HOWEVER THE PARTICLES IN THE FUEL TANK ARE STILL PRESENT. PIC…
07/06/2020 · Fuel system
THE MOTORCYCLE WILL FOR NO KNOWN REASON EXHIBIT A FUEL DELIVERY ISSUE AND BOG THE ENGINE, AS IN, IT WILL NOT DELIVER ANY POWER TO THE ENGINE. THIS IS UNSAFE DURING HIGHWAY SPEEDS AND AT INTERSECTIONS WHEN YOU ARE TRYING TO PROCEED WITH EXECUTING A MANEUVER.
07/02/2020 · Fuel system
THE VEHICLE WILL STOP ACCELERATING ON AN INCLINE, VERY DANGEROUS WHILE TRYING TO PASS SLOWER MOVING VEHICLES IN THE MOUNTAINS. THE ISSUE WOULD TAKE PLACE BETWEEN SPEEDS OF 25MPH-70MPH. THE MOTORCYCLE WILL KILL SOMEONE IN THE WRONG SITUATION. PLEASE HELP TO STOP THE MANUFACTURER FROM PLACING UNSATISFACTORY VEHICLES ON THE ROAD.