2002 Honda Insight recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. ON CERTAIN PASSENGER VEHICLES, THE LOW-BEAM TERMINAL ON THE HEAD LIGHT WIRE HARNESS CAN OVERHEAT AND COULD CAUSE THE LOW BEAMS TO FAIL WITHOUT WARNING.
What could happen: AN UNEXPECTED LOSS OF LOW BEAMS COULD RESULT IN A CRASH.
The fix: DEALERS WILL INSPECT THE HEAD LIGHT SWITCH AND COUPLER FOR SIGNS OF HEAT DAMAGE. IF HEAT DAMAGE IS PRESENT, THE DEALER WILL REPLACE THE SWITCH AND COUPLER. IF NO HEAT DAMAGE IS PRESENT, THE DEALER WILL REPLACE THE HEAD LIGHT SWITCH AND ONE MATING PIN IN THE COUPLER. OWNER NOTIFICATION BEGAN ON APRIL 5, 2004. OWNERS…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 INSIGHT.
- Book a repair at any authorized Honda dealer. Quote NHTSA campaign 04V086000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-999-1009.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: ON CERTAIN PASSENGER VEHICLES, THE LOW-BEAM TERMINAL ON THE HEAD LIGHT WIRE HARNESS CAN OVERHEAT AND COULD CAUSE THE LOW BEAMS TO FAIL WITHOUT WARNING.
Consequence: AN UNEXPECTED LOSS OF LOW BEAMS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE HEAD LIGHT SWITCH AND COUPLER FOR SIGNS OF HEAT DAMAGE. IF HEAT DAMAGE IS PRESENT, THE DEALER WILL REPLACE THE SWITCH AND COUPLER. IF NO HEAT DAMAGE IS PRESENT, THE DEALER WILL REPLACE THE HEAD LIGHT SWITCH AND ONE MATING PIN IN THE COUPLER. OWNER NOTIFICATION BEGAN ON APRIL 5, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Lights (8), Transmission / drivetrain (6), Electrical system (3), Airbags (2), Vehicle Speed Control (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
01/07/2016 · Lights
TL* THE CONTACT OWNS A 2002 HONDA INSIGHT. WHILE DRIVING AT VARIOUS SPEEDS, THE LOW BEAM HEADLIGHTS FAILED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS MELTED AND CAUSED THE LOW BEAM FAILURE AND THAT THE LIGHT SWITCH AND CONNECTOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT RE…
07/25/2014 · Lights
TL* THE CONTACT OWNS A 2002 HONDA INSIGHT. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE LOSS EXTERIOR AND INTERIOR LIGHTING. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V086000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE…
03/28/2013 · Lights
TL* THE CONTACT OWNS A 2002 HONDA INSIGHT. THE CONTACT STATED THAT WHENEVER THE HEADLIGHTS WERE ACTIVATED THEY WOULD FAIL INTERMITTENTLY AT UNKNOWN, INTERVALS AT RANDOM.. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE HEADLIGHT SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED…
12/06/2011 · Lights
TL* THE CONTACT OWNS A 2002 HONDA INSIGHT. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WITH THE LOW BEAM HEADLIGHTS ACTIVATED WHEN THEY SUDDENLY FAILED TO ILLUMINATE. IMMEDIATELY, THE HIGH BEAMS WERE ACTIVATED. THE CONTACT REPLACED BOTH LOW BEAM BULBS AND THE FAILURE CONTINUED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 04V086000 (EXTERIOR LIGHTING…
12/29/2010 · Lights
TL*THE CONTACT OWNS A 2002 HONDA INSIGHT. WHILE DRIVING 35 MPH, THE LOW BEAM SWITCH BURNED OUT. THE CONTACT SMELLED A BURNING ODOR WHEN THE HEADLIGHTS BLEW OUT. THE DEALER STATE THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 04V086000 (EXTERIOR LIGHTING: HEADLIGHTS). THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO VERIFIED THAT THE V…
01/24/2009 · Transmission / drivetrain
2002 HONDA ODYSSEY TRANSMISSION FAILURE NOTHING. *TR
11/03/2008 · Lights
TL*THE CONTACT OWNS A 2002 HONDA INSIGHT. WHILE DRIVING APPROXIMATELY 50 MPH AT NIGHT, THE HIGH BEAMS WERE ACTIVATED. WHEN THE CONTACT ATTEMPTED TO ACTIVATE THE LOW BEAM LIGHTS, THEY COMPLETELY DIMMED. THE VEHICLE WAS RETURNED TO HER RESIDENCE AND HER HUSBAND REPLACED THE BULBS AND CHECKED THE RELAY. HER HUSBAND THOUGHT THAT THE RELAYS NEEDED TO BE REPL…
06/17/2008 · Electrical system
WHEN MEASURED WITH A TRIFIELD METER, THE ELECTROMAGNETIC FIELD (EMF) IMPACTING THE DRIVER AND PASSENGER ARE DANGEROUSLY HIGH. THE DRIVER IS RECEIVING UP TO 135 MILLIGAUSS (MG) AT THE HIP, AND UP TO 100 MG IN THE UPPER TORSO AND HEAD AREA. (UNDER 10 MG IS CONSIDERED SAFE.) SEE HTTP://CONSUMERAFFAIRS.COM/AUTOMOTIVE/HONDA_INSIGHT.HTML. *TR