2012 Hyundai Santa Fe recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
What could happen: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
The fix: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. Owners may contact…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2012 SANTA FE.
- Book a repair at any authorized Hyundai dealer. Quote NHTSA campaign 20V746000 (manufacturer code 198).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-855-371-9460.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE
Summary: Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
Consequence: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 198.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2012 Hyundai Santa Fe owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (234), Electrical system (43), Vehicle Speed Control (40), Brakes (28), Transmission / drivetrain (24).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/17/2026 · Body / structure
The contact owns a 2012 Hyundai Santa Fe. The contact stated that the underbody of the vehicle was rusted from living in an area where anti-icing agents were heavily used. The contact associated the failure with Hyundai Service Campaign 947. The dealer was contacted and stated that the vehicle was previously repaired under Hyundai Service Campaign 947 in 20…
06/22/2026 · Engine
On June 16, 2025, I dropped my 2012 Hyundai Santa Fe GLS (VIN: [XXX]) off at Larry H. Miller Southwest in Albuquerque, NM for NHTSA safety recall #20V746000 (Theta II engine connecting rod bearing failure). It has now been over one week with zero communication from the dealership regarding the status of my vehicle. When I attempted to follow up by phone I…
05/11/2026 · Electrical system
The contact purchased a 2012 Hyundai Santa Fe. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 71,000 and at the time of registration, it was discovered that the mileage on the title 43,655 and the DMV in…
03/26/2026 · Suspension
Rear subframe suddenly collapsed and broke due to extreme corrosion. Incident occurred while driving, allowing rear wheel to turn out causing loss of control. Luckily I was traveling at a low rate of speed and nobody was hurt. Found rear subframe was completely rotten out and collapsed on the driver side. Vehicle is now completely undrivable and has to…
03/09/2026 · Unknown Or Other · fire
The engine rod broke creating a big whole in the engine which caused the engine and underneath of car to start on fire. There was a massive recall for this same issue in 2021-2023 for the year car! It is available for inspection! Yes safety was at risk, the car was on fire on the Highway in the middle of rush hour. The problem was confirmed by Progressive a…
11/21/2025 · Engine · fire
My 2012 Hyundai Santa Fe caught fire on October 29, 2025. Prior to this, the dealership completed one recall but left another open. Hyundai denied my claim and refused to provide the inspection report. I am filing this complaint because I believe the incomplete recall may be related and I want NHTSA to review the issue.
09/30/2025 · Engine
The contact owns a 2012 Hyundai Santa Fe. The contact stated that while driving 80 MPH, the vehicle made an abnormally loud banging sound, and there was smoke coming from underneath the hood and through the A/C vents, which blocked the visibility of the roadway. The contact was able to pull over to the side of the road. Upon inspecting the vehicle, the cont…
08/11/2025 · Engine
The carrier bearing failed and caused the engine to lock up while driving, thankfully we weren't on a busy road and were able to coast off the road. There was no prior light that appeared. We are just thankful it wasn't our 16 year old, newly licensed driver for whom we purchased the vehicle, driving. It has not been looked over by the dealership yet as the…