1999 Hyundai Sonata Gls recalls & complaints

Component: SUSPENSION
Summary: HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.
Consequence: IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Notes: HYUNDAI RECALL NO. 089. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: ELECTRICAL SYSTEM:WIRING
Summary: VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.
Consequence: THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.
Notes: HYUNDAI RECALL NOS. 039 AND 040. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: AIR BAGS:SIDE/WINDOW
Summary: ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE SIDE IMPACT AIR BAGS AND COULD PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR.
Consequence: NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAG COULD INCREASE THE RISK OF INJURY DURING A SIDE IMPACT CRASH.
Remedy: DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: AIR BAGS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE DRIVER AND/OR PASSENGER SEAT-MOUNTED SIDE IMPACT AIR BAG(S).
Consequence: THIS CONDITION COULD PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING AN ACCIDENT WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAGS COULD INCREASE THE RISK OF INJURY DURING AN ACCIDENT WHERE SIDE IMPACT AIR BAG DEPLOYMENT IS INTENDED.
Remedy: DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

07/21/2015 · Suspension
TL* THE CONTACT OWNS A 1999 HYUNDAI SONATA GLS. WHILE MAKING A LEFT TURN AT A TRAFFIC LIGHT, THE FRONT PASSENGER SIDE SUSPENSION SEPARATED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS INCLUDED IN NHTSA ACTION NUMBER: EA08016 (STRUCTURE, SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE…

04/03/2013 · Suspension
I OWN A 1999 HYUNDAI SONATA AND WAS INFORMED BY MY MECHANIC THAT THE FRONT SUB FRAME ON THE PASSENGER SIDE IS RUSTING THROUGH, PRESENTING A SEVERE SAFETY RISK TO THE DRIVER AND PASSENGERS. THERE IS CURRENTLY A MANUFACTURER'S RECALL SHOWING FOR THE 2001-2004 MODEL FROM YOUR INVESTIGATION. SHOULDN'T THE 1999 BE INCLUDED DUE TO IT HAVING MANY COMPLAINTS DUE TO…

03/27/2011 · Airbags
1999 HYUNDAI SONAT GLS AIRBAG WARNING LIGHT CONTINUES TO COME ON AFTER BEING WORKED ON BY HYUNDAI DEALER 10-15 TIMES. WAS WORKED ON WITHOUT ISSUE WHILE UNDER WARRANTY WITH NO SUCCESS. ONCE EXTENDED WARRENTY EXPIRED, THE DEALER THEN KNEW THAT THE CAR NEEDED A NEW WIRE HARNESS FOR ABOUT $1000. THE SERVICE MANAGER THEN SUGGESTED THAT I HARD -WIRE THE WIRE H…

10/18/2010 · Suspension
VEHICLE HAD DEVELOPED A FRONT END ALIGNMENT PROBLEM, AND I SCHEDULED AN ALIGNMENT. THE MORNING BEFORE THE SCHEDULED ALIGNMENT, I WAS PULLING OUT OF MY DRIVEWAY TO GO TO WORK WHEN THE RIGHT INNER CV JOINT DISINTEGRATED. INVESTIGATION REVEALED SEVERE SUBFRAME CORROSION RESULTING IN THE CONTROL ARM MOUNT SEPARATING FROM THE SUBFRAME, CAUSING THE CV JOINT TO FA…

10/05/2010 · Suspension
I HAVE A DEFECTIVE SUBFRAME ON A 1999 SONATA PURCHASED NEW IN IOWA AND DRIVEN THERE FOR 4 YEARS. IT HAS COMPLETELY RUSTED OUT ON THE PASSENGER FRONT SIDE CAUSING STEERING CONTROL ARMS AND DRIVE AXLE TO BREAK LOOSE FROM VEHICLE AND MAKING VEHICLE INOPERABLE. THIS SHOULD BE COVERED UNDER HYUNDAI RECALL CAMPAIGN 089. NHTSA CAMPAIGN ID NO. 09V124000. I AM G…

01/23/2010 · Body / structure
I OWN A 1999 HYUNDAI SONATA AND WAS INFORMED BY MY MECHANIC THAT THE FRONT SUB FRAME ON THE PASSENGER SIDE IS RUSTED THROUGH, PRESENTING A SEVERE SAFETY RISK TO THE DRIVER AND PASSENGERS. THERE IS CURRENTLY A MANUFACTURER'S RECALL DUE TO THIS CORROSION ISSUE. THE VEHICLE WAS PURCHASED AND DRIVEN IN MINNESOTA FOR THE LAST TEN YEARS WHERE SALT IS APPLIED TO R…

10/01/2009 · Suspension
ON 1 OCT 2009 MY SON WAS DRIVING HIS 1999 HYUNDAI SONATA GLS FROM HIS HIGH SCHOOL TO PICK UP HIS SISTER AT THE DAYCARE JUST DOWN THE ROAD. UPON PULLING INTO THE DAYCARE PARKING LOT HE HEARD A LOUD SOUND AND THE FRONT PASSENGER SIDE OF THE VEHICLE DROPPED SIGNIFICANTLY. HE IMMEDIATELY STOPPED THE VEHICLE AND GOT OUT TO SEE IF HE HAD HIT SOMETHING OR TO SEE…

06/27/2009 · Body / structure
DRIVING DOWN THE ROAD THE CAR BEGAN TO PULL TO THE RIGHT. COULD BARELY DRIVE TO THE SHOP. THEY FOUND OUT THE FRAME WAS RUSTED SO BAD IT WAS NOT DRIVABLE. THE TIRE WHICH WERE NEW JUST 3 MONTHS AGO WERE TOTALLY BALD. THE CAR, A 1999 HYUNDAI SONATA, IS NOW NOT DRIVABLE. *TR