1997 Hyundai Tiburon recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST IN THE D-RING GUIDES AND MAKE IT INCONVENIENT TO EXTEND AND RETRACT THE SEAT BELTS.
What could happen: IF THE SEAT BELTS ARE INCONVENIENT TO USE, THE SEAT OCCUPANT MAY NOT BE INCLINED TO WEAR THE SEAT BELTS PROPERLY, INCREASING THE RISK OF INJURY IN THE EVENT OF A CRASH.
The fix: DEALERS WILL INSTALL A STOPPER OVER EACH FRONT SEAT BELT D-RING GUIDE TO ASSIST THE SEAT BELT TO SMOOTHLY EXTEND AND RETRACT. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME S…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 TIBURON.
- Book a repair at any authorized Hyundai dealer. Quote NHTSA campaign 01V345000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-633-5151.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:WEBBING
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST IN THE D-RING GUIDES AND MAKE IT INCONVENIENT TO EXTEND AND RETRACT THE SEAT BELTS.
Consequence: IF THE SEAT BELTS ARE INCONVENIENT TO USE, THE SEAT OCCUPANT MAY NOT BE INCLINED TO WEAR THE SEAT BELTS PROPERLY, INCREASING THE RISK OF INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A STOPPER OVER EACH FRONT SEAT BELT D-RING GUIDE TO ASSIST THE SEAT BELT TO SMOOTHLY EXTEND AND RETRACT. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.
What could happen: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
The fix: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 TIBURON.
- Book a repair at any authorized Hyundai dealer. Quote NHTSA campaign 00V095001.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.
Notes: OWNER NOTIFICATION BEGAN APRIL 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.
What could happen: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
The fix: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 TIBURON.
- Book a repair at any authorized Hyundai dealer. Quote NHTSA campaign 00V095002.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.
Notes: OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-981-0452. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
4. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.
What could happen: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 TIBURON.
- Book a repair at any authorized Hyundai dealer. Quote NHTSA campaign 97V026000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Summary: THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.
Consequence: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.
Notes: OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 18, 1997. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-829-9956. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1997 Hyundai Tiburon owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (9), Airbags (8), Fuel system (6), Gasoline (6), Visibility (wipers / glass) (6).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/05/2014 · Fuel system
TL* THE CONTACT OWNS A 1997 HYUNDAI TIBURON. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE SERVICED UNDER NHTSA CAMPAIGN NUMBER: 00V095001 (FUEL SYSTEM, GASOLINE), THERE WAS A PERSISTENT STRONG SMELL OF FUEL. THE CONTACT REMOVED THE BACK SEAT TO INSPECT THE ACCESS PORT FOR THE FUEL TANK AND DISCOVERED A 4 INCH FRACTURE ON THE STEEL FUEL TANK. THE CONTACT…
11/04/2009 · Fuel system
TL* THE CONTACT OWNS A 1997 HYUNDAI TIBURON. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE IT REPAIRED ACCORDING TO RECALL CAMPAIGN ID NUMBER 00V095002 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THERE WAS NOT A REMEDY REPAIR PERFORMED ON THE VEHICLE. AFTER THE INSPECTION THE "CHECK ENGINE" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE AU…
03/26/2008 · Fuel system
TL*THE CONTACT OWNS A 1997 HYUNDAI TIBURON. WHILE DRIVING APPROXIMATELY 50 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND A LEAK IN THE FUEL TANK AS DETERMINED BY A PRESSURE CHECK. HYUNDAI WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MIL…
09/22/2005 · Fuel system
SMELLED GAS FUMES STRONGLY UPON FILL-UP FOR SEVERAL DAYS, CHECK ENGINE LIGHT. TOOK CAR IN. MECHANIC SAID RECALL #00V095002 WAS IN EFFECT ON MY VEHICLE. TOOK IT TO DEALERSHIP TO HAVE THEM REPLACE DEFECTIVE PARTS (TANK & CAP). DEALERSHIP ONLY REPLACED CAP BUT DID NOT TELL ME AT THE TIME. WENT TO SMOG CAR NEXT YEAR AND COMES UP WITH EVAPORATIVE LEAK. TOO…
12/28/2004 · Electrical system
CHECK ENGINE LIGHT CAME ON WHILE DRIVING AND CAR BEGAN TO HEAT UP, THE DRIVER SIDE AIRBAG CAME ON AS WELL;TOOK IT IN FOR MAINTENANCE AND THE ALTERNATOR WAS REPLACED HOWEVER THE AIRBAG PROBLEM WAS NOT CORRECTED AND REMAINS ON. *JB
10/22/2004 · Electrical system
CONNSUMER STATED ELECTRICAL SYSTEM FAILED. *AK
02/17/2004 · Seat belts
CONSUMER STATED DRIVER'S FRONT SEAT BELTS DID NOT HOLD THE PASSENGER IN THE SEAT. DEALER INDICATED THERE WAS NO RECALL ON FRONT SEAT BELT. *AK
05/11/2003 · Latches / locks · crash
WHILE DRIVING THE HOOD LATCH FAILED AND THE HOOD FLEW UP ONTO THE WINDSHIELD, DESTROYED THE HOOD AND LATCHES, DAMAGED THE ROOF, AND INJURED DRIVER. *NLM