1993 Lincoln Town Car recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Summary: IMPROPER INSTALLATION OF THE REAR BRAKE LINE AT THE POINT AT WHICH THE EXTENDED BRAKE LINE FIRST BENDS AND EXTENDS OVER THE LEFT REAR WHEEL AREA OF THE FRAME. IF NOT INSTALLED WITH SUFFICIENT CLEARANCE, CHAFING OF THE BRAKE LINE CAN OCCUR IN AN AREA ADJACENT TO THE REAR FLOOR PAN.
Consequence: THE REAR BRAKE LINE CAN LEAK OR RUPTURE RESULTING IN REDUCED BRAKING CAPABILITY, LOSS OF REAR BRAKES, AND/OR LOSS OF BRAKE FLUID RESERVES IN THE MASTER BRAKE CYLINDER.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE FOR PROPER INSTALLATION AND/OR DAMAGE AND REPLACE AS NECESSARY. ALSO A PROTECTIVE BOOT OR SLEEVE OVER THE BRAKE LINE WILL BE INSTALLED.
Notes: SYSTEM: BRAKES; HYDRAULIC; LINES; NON-METALLIC. VEHICLE DESCRIPTION: LINCOLN TOWNCARS REMANUFACTURED INTO STRETCH LIMOUSINES BY DABRYAN COACH BUILDERS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT DABRYAN AT 1-417-864-4411. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: ELECTRICAL SYSTEM
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
Notes: FORD RECALL NO. 99S15. THIS RECALL HAS BEEN SUPERSEDES BY FORD RECALL NO. 05S28 (PLEASE SEE 05V017, 05V388, 06V286 AND 07V336). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 18, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

08/23/2019 · Vehicle Speed Control
I WAS WORKING ON DOING MAINTENANCE ON MY CAR. NEXT THING I KNOW, THERE'S A FIRE. I GOT IT OUT QUICKLY ENOUGH WITH THE ORIGINAL EXTINGUISHER. THE SPEED CONTROL HARNESS, WHICH HAD A RECALL AT ONE POINT, IS BURNED AND A BRAKE LINE BUSTED. 9F924 IS THE NUMBER FOR THE PART. I DO NOT KNOW FOR CERTAIN IF THIS WAS EVER REPLACED. BUT IT MUST HAVE BEEN HOT ENOUGH TO…

07/28/2015 · Transmission / drivetrain
TL* THE CONTACT OWNS A 1993 LINCOLN TOWN CAR. ONCE THE VEHICLE WAS STARTED, IT BEGAN TO MAKE A JERKING MOTION AND ALL OF THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE FAILURES RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEA…

12/08/2014 · Electrical system · fire
TL* THE CONTACT OWNS A 1993 LINCOLN TOWN CAR. WHILE DRIVING 60 MPH, THE CONTACT OBSERVED SMOKE EMITTING FROM THE DRIVER SIDE OF THE DASHBOARD AND THE FUSE BOX. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

07/05/2011 · Electrical system · fire
THE CAR HAD BEEN DRIVEN LIKE EVERY OTHER DAY.THE CAR HAD BEEN PARKED IN MY DRIVE WAY FOR ABOUT 3 TO 4 HOURS.I WAS INSIDE MY HOUSE WHEN I HEARD SOMEONE HONKING OUTSIDE.WHEN I LOOKED OUT THE WINDOW THE CAR WAS SMOKING FROM UNDER THE HOOD.I GOT MY PHONE AND CALLED 911.BY TIME THE FIRE DEPARTMENT SHOWED UP THE CAR WAS ALREADY IN FLAMES. *KB

12/20/2010 · Electrical system · fire
I PURCHASED A USED 1993 LINCOLN TOWN CAR ON DEC 17. ON DECEMBER 19 THE VEHICLE CAUGHT FIRE IN THE GARAGE. IT HAD NOT BEEN DRIVEN SINCE PURCHASE OR STARED. FIRE CAUSED SEVERE DAMAGE TO GARAGE. COMPLETELY BURNED THE CAR. FIRE DEPARTMENT CAME AND THE INVESTIGATOR STATED IT WAS SPEED CONTROL , SINCE I JUST PURCHASED THE VEHICLE I WAS UNAWARE OF THE RECALL. *TR

01/29/2010 · Lights · fire
BRAKE LIGHTS WENT OUT SO WE REPLACED THE BULBS TO NO AVAIL. REPLACED THE FUSE AND FIXED THE BRAKE LIGHTS. DROVE CAR TO WORK AND BACK THURSDAY 1/28/10. PARKED CAR IN DRIVEWAY AT 7PM. AWOKEN AT 3AM TO CAR ENGINE COMPLETELY IN FLAMES. RESEARCHED AND FOUND A RECALL NHTSA CAMPAIGN ID #: 99V124000. DAMAGE TO SURROUNDING HOUSES AND NEARBY CAR. *TR

01/25/2010 · Electrical system
DASH CONTROL MODULE THAT CONTROLS VEHICLE SPEEDOMETER AND ODOMETER CAUSES ALL THE DIGITAL DASH THE FLASH LIKE STROBE LIGHTS. DRIVER CAN DETERMINE SPEED OF VEHICLE AND ODOMETER RECORDS INTERMITTENTLY. D CAR ALSO HAS A SMELL OG BURNING WIRES OR PLASTIC. *TR

09/14/2009 · Vehicle Speed Control · fire
MY 1993 LINCOLN TOWN CAR CAUGHT FIRE AND BURNED UP. THE CAR HAD BEEN PARKED OUTSIDE FOR SEVERAL HOURS BEFORE HE FIRE STARTED. THE FORD COMPANY CLAIMED (BASED ONLY ON PICTURES THAT I SENT THEM) THAT THERE WAS TOO MUCH FIRE DAMAGE TO DETERMINE WHETHER THE FIRE WAS A RESULT OF A DEFECTIVE PART WHICH HAD A RECALL.. THE FIRE DEPARTMENT'S REPORT, WHICH I ALS…