2004 Mazda Mpv recalls & complaints

Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Summary: Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 16V354.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Summary: Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: This recall supersedes recalls 13V130, 14V362, 14V773 and 15V869.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EQUIPMENT:OTHER:LABELS
Summary: THE TIRE INFLATION PRESSURE INDICATED ON THE VEHICLE CERTIFICATION LABEL IS NOT CORRECT. THE LABELS SHOW THE MAXIMUM TIRE PRESSURE AS 240 KPA/32 PSI WHEN IT SHOULD BE SHOWN AS 240 KPA/35 PSI. AS A RESULT OF THIS ERROR, THE LOAD RATIOS FOR THE 205/65R15 94H AND THE 215/60R16 95H TIRES EXCEED THE LEVELS PERMITTED BY FMVSS 120.
Consequence: IF THE TIRE IS OPERATED IN AN UNDER-INFLATED CONDITION, THE LOAD CARRYING CAPACITY OF THE VEHICLE MAY BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL THAT THEY CAN APPLY TO THEIR VEHICLE, OR THEY CAN HAVE A DEALER INSTALL THE LABEL, IF DESIRED. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500, OPTION #4.
Notes: MAZDA RECALL NO. 2140F. CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: AIR BAGS:FRONTAL
Summary: AS A RESULT OF AN NCAP TEST, CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE FRONT PASSENGER SEAT AIR BAG WAS NOT CORRECTLY WIRING.
Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT PROVIDE ADEQUATE PROTECTION.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS IN THE FRONT PASSENGER SEAT AIR BAG SYSTEM. THE RECALL BAGAN MARCH 5, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
Notes: MAZDA RECALL NO. 1604B-A. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: EQUIPMENT:OTHER:LABELS
Summary: CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE PRODUCED WITH AIR BAG WARNING LABELS INTENDED FOR THE CANADIAN MARKET. THUS, THE LABELS CONTAIN WARNINGS IN BOTH ENGLISH AND FRENCH. AS A RESULT, THE AREA OF THE ENGLISH WARNING IS ONLY 16 SQUARE CENTIMETERS, AS OPPOSED TO THE 30 SQUARE CENTIMETERS REQUIRED BY THE STANDARD.
Consequence:
Remedy: OWNERS WILL BE PROVIDED WITH AIR BAG CAUTION LABELS AND INSTALLATION INSTRUCTIONS WHICH WERE MAILED ON JULY 22, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
Notes: MAZDA RECALL NO. 1804C. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

09/21/2021 · Unknown Or Other
2004 MAZDA MPV. CONSUMER WRITES ASKING TO BE REMOVED FROM RECALL LIST BECAUSE THEY NO LONGER OWN THE VEHICLE.

12/06/2018 · Unknown Or Other
FRONT CROSS MEMBER CORROSION; FRAME DAMAGED; CAR DANGEROUSLY UNSTABLE. WHEEL ALIGNMENT COST ME $72.64 AND FRAME REPAIR COST $693.36. THE VEHICLE IN THE SHOP FOR 4 DAYS. MENTAL ANGUISH. MAZDA DEALER DECLINED REPAIRS. MAZDA CUSTOMER SERVICE DECLINED TO PAY. NOW THEY ARE ADMITTING THAT PROBLEM ON MAZDA 6 VEHICLES. IT'S AN OLD PROBLEM PROBABLY RELATED TO METAL…

10/19/2018 · Suspension
SUSPENSION SUBFRAME RUSTED AND CRACKED.

07/31/2018 · Airbags · crash
TL* THE CONTACT OWNS A 2004 MAZDA MPV. WHILE THE CONTACT'S WIFE WAS DRIVING 15 MPH, SHE STRUCK ANOTHER VEHICLE ON THE DRIVER'S SIDE DOOR. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN UNKNOWN LOCATION. THE VEHICLE WAS NOT TAKEN TO A DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURE…

06/28/2017 · Airbags
I WENT INTO THE DEALERSHIP TO GET MY SAFETY RECALLS DONE AT THE MAZDA DEALERSHIP ON TORRANCE BUT THEY SAID I NEEDED TO FILL OUT A FORM AND TO WAIT FOR THEM TO RECEIVE THE AUTO PARTS. IT HAS BEEN MORE THAN 6 MONTHS SINCE I WENT, I HAVE NOT HEARD FROM THE AT ALL.

06/20/2017 · Airbags
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) WAS RECEIVED IN MAY OF 2016. AFTER CONTACTING THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING…

04/24/2017 · Airbags
AIR BAG INFLATOR REPLACEMENT FIRST NOTICE REC.8/1/16,CALLED BOMARITO(LOCAL DEALER)-NO PARTS-WOULD CALL CALLED AGAIN1/2/17-SAME RESPONSE SECOND NOTICE REC.4/17/17-CALLED AGAIN SAME RESPONSE.

02/24/2017 · Airbags
TAKATA RECALL: I RECEIVED MAZDA OFFER TO REPLACE DEFECTIVE PART AND ACCOMMODATE FOR TRANSPORTATION WHILE THE CAR IS BEING REPAIR. THE ONLY REQUIREMENT TO HAVE THIS ACCOMMODATIONS IS TO MAKE AN APPOINTMENT FOR THEM TO DELIVER SUCH OFFER TO FIX THE INCONVENIENCES THAT THIS BRINGS. I CALLED TO MAKE THE ARRANGEMENTS BUT NOW MAZDA REFUSES TO GIVE ANOTHER TRANSPO…