2004 Mercedes-Benz Sl-Class recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2004 Mercedes-Benz Sl-Class owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Suspension (23), Brakes (16), Fuel system (12), Gasoline (7), Electrical system (6).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/05/2026 · Brakes
The contact owns a 2004 Mercedes-Benz SL500. The contact stated that after starting the vehicle, the message "Brakes Reached Historic Threshold" was displayed, which indicated that the brake control unit had malfunctioned. Additionally, while depressing the brake pedal, the brake pedal was spongy, causing the stopping distance to become extended. The vehicl…
01/24/2026 · Brakes
Question 1: The Sensotronic Brake Control (SBC) unit, which is a high-pressure "brake-by-wire" hydraulic system. Component A7/3. The component is currently installed in the vehicle and is available for inspection. Question 2: The vehicle experienced a sudden, catastrophic loss of hydraulic brake pressure while in operation. This failure required extreme ph…
12/03/2025 · Electrical system
The safety component that is covered under the SBC warranty is the entire brake master cylinder specifically the part that is bad is the brake pedal position sensor The car is undriveable without it, they have a 25-year warranty on it yet they have no parts and no way to fix it which is obviously unacceptable they've also refused to provide a loaner car unt…
11/29/2023 · Electrical system
Mercedes SL600 BCM has electrical issues leading to a fire it is available for inspection. The car can burn down in a garage putting me and all others in or near the dwelling at risk. Yes the problem has been confirmed independently. No BCM issues lead to red light on dash.
04/23/2023 · Electrical system · fire
The 2003-2006 R230 series seem to have a problem with the BCM (Battery Control Module) as start an electrical fire in the trunk. Very common issue and a safety hazard - this is what happened with my car. Vehicle has dual battery, starter in front, convenience battery in trunk and fuses that operate at 130 Amps - the BCM capacitors and circuit board age and…
05/07/2022 · Fuel system
On many 2003 and 2004 models. Broken fuel tank baffle inside fuel tank. This is well documented and could possibly cause explosion.
07/30/2020 · Fuel system
ON JULY 22, 2020 THE VEHICLE (2004 MERCEDES-BENZ SL500 (R230)BEGAN MAKING A LOUD BANGING NOISE IN THE REAR WHEN STOPPING AND TURNING. I DELIVERED THE VEHICLE TO A LOCAL SHOP WHERE THE VEHICLE WAS DIAGNOSED AS HAVING A BROKEN BAFFLE IN THE FUEL TANK. THE ONLY SOLUTION IS TO REPLACE THE ENTIRE FUEL TANK. MANY OTHER OWNERS OF THIS MODEL HAVE EXPERIENCED THE SA…
06/29/2020 · Suspension
TL* THE CONTACT OWNS A 2004 MERCEDES-BENZ SL500. THE CONTACT STATED ON VARIOUS OCCASIONS WHILE HIS VEHICLE WAS STATIONERY AND IN PARK, EITHER THE RIGHT SIDE OR THE LEFT SIDE OF THE VEHICLE WOULD RAISE UP THEN DESCEND TO GROUND OVER A THIRTY SECOND PERIOD INDEPENDENTLY WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE HYDRAULIC FLUID LEAKED OUT OF THE ENGINE…