2023 Mercedes-Benz Sprinter 2500 Cargo Van (lwb) recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2023 Mercedes-Benz Sprinter 2500 Cargo Van (lwb) owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (6), Transmission / drivetrain (5), Fuel system (5), Unknown Or Other (4), Electrical system (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/11/2026 · Transmission / drivetrain
The High-Pressure Fuel Pump (HPFP) and corresponding fuel delivery pressure regulator/sensors have suffered an internal mechanical failure. The system intermittently fails to maintain commanded rail pressure, leading to critical engine cylinder misfires (P0302, P0304) and severe long-term fuel adaptation breaches (P00C600, P008992, P017184, P218862). This d…
10/08/2026 · Electrical system
The ECM harness was wired too close to a sharp metal piece within the engine bay, the clip MBZ uses to secure it was insufficient to hold it back, the thick wiring harness got caught on the metal piece and overtime got cut deeply causing a short with thermal issues spreading to other components, the wiring harness melted together and caused so much heat in…
07/03/2026 · Electrical system · fire
On January 19, 2026, my neighbors / daughter noticed smoke was coming from under the van that had been parked for over 3 hours. Shortly after, he confirmed the van had caught fire. I asked him to call the fire department.
03/24/2026 · Unknown Or Other
In August 2025, I had taken the van for a drive to charge things up, got home, put it in park and parked it in my driveway, which has a mild slope. ~ 30 seconds - 1 minute after me leaving the vehicle, it rolled backward out of the driveway, across a busy street and 1/4 into my neighbors yard. I was mortified, there is usually a lot of people walking their…
11/21/2025 · Wheels / tires
2023 Sprinter van jack was pulled out for the first time to be used last week and found to be unsafe. The jack base is crowned in center, the edges flare upwards and large gouge/groove in metal base, causing the jack to noticeably wobble and rock in manner that it is unsafe to use, fear of jack tilting and dropping van onto user of jack. Jack base has obvio…
10/01/2025 · Engine
I had tuned up my sprinter van around 64000 miles. I put new ngk spark plugs and ignition coils on it. Ran for a day then. The codes said the number one ignition coil was bad. Change that out and it ran for about 8000 miles. Then stated to go in lymph mode again. I decided to replace them with original Mercedes spark plugs and Ignition coils. But when I put…
08/30/2025 · Engine
In Colorado. Vehucle has no response when pushing on the gas pedal. Dead pedal at a light in Gunnison and now again at my home at 9,450 ft.
07/15/2025 · Engine
Occasionally, the idle speed of the engine will drop to 400 rpm. When this happens, the vehicle does not respond to throttle input. If it happens in a parking lot, you can shift into park and coax the rpm higher, then shift to drive and move on. When it happens in the middle of an intersection while waiting to make a left turn, the story is very differen…