2000 Mitsubishi Galant recalls & complaints

Component: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A NUT IN THE STEERING GEAR ASSEMBLY WAS NOT PROPERLY TIGHTENED, RESULTING IN SYMPTOMS RANGING FROM STEERING WHEEL VIBRATION TO STIFF STEERING, AND IN THE WORST CASE, NO ABILITY TO TURN LEFT.
Consequence: A LOSS OF STEERING CONTROL COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE STEERING GEAR ASSEMBLY IF A LOOSE NUT CONNECTION IS FOUND.
Notes: OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH V6 ENGINES TO FEDERAL EMISSION STANDARDS. THE POWER STEERING FLUID FEED TUBE CAN COME IN CONTACT WITH AN EXHAUST MANIFOLD MOUNTED HEAT SHIELD CAUSING A HOLE TO BE WORN THROUGH THE POWER STEERING PIPE ALLOWING FLUID LEAKAGE.
Consequence: LEAKING POWER STEERING FLUID CAN RESULT IN A FIRE AND CONTINUED LOSS OF FLUID WILL RESULT IN A LOSS OF POWER ASSIST, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE POWER STEERING TUBE WITH ONE HAVING A NEW ROUTING. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-800-222-0037.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: EQUIPMENT:OTHER:LABELS
Summary: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Notes: THE MANUFACTURER'S PETITION WHICH REQUESTED THAT NHTSA DETERMINE THIS FMVSS NONCOMPLIANCE DOES NOT CREATE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY WAS PARTIALLY DENIED ON JANUARY 26, 2005. THEREFORE, THIS MANUFACTURER IS OBLIGATED TO CONDUCT AN OWNER NOTIFICATION AND REMEDY CAMPAIGN. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH V6 ENGINES AND FEDERAL EMISSION EQUIPMENT. THE BATTERY CABLE HARNESS CAN BECOME HEAT DAMAGED BY THE FRONT EXHAUST MANIFOLD WHICH COULD CAUSE GROUNDED CIRCUITS.
Consequence: THIS CIRCUIT FAILURE COULD CAUSE ANY OF THE FOLLOWING TO OCCUR: (1) THE ENGINE WILL NOT START BECAUSE THE MAIN FUSE WILL BLOW IF THE POWER LEAD IS GROUNDED; (2) THE LOW OIL PRESSURE WARNING LAMP WILL ILLUMINATE IF THE SIGNAL WIRE IS GROUNDED; (3) THE AIRCONDITIONING SYSTEM WILL BECOME INOPERATIVE IF THE LEAD TO THE MAGNETIC CLUTCH IS GROUNDED; AND (4) THE TURN SIGNAL/HAZARD LAMPS WILL BECOME INOPERATIVE IF THE VOLTAGE MONITOR LEAD IS GROUNDED.
Remedy: DEALERS WILL REMOVE AND DISCARD A METAL MANIFOLD BRACKET (FROM GALANT MODELS ONLY - ECLIPSE HAS NO SUCH BRACKET). DEALERS WILL ALSO INSPECT THE HARNESS. IF THE HARNESS WIRES SHOW NO DAMAGE, THE DEALER WILL INSTALL A HEAT INSULATOR ALONG WITH HEAT RESISTANT HARNESS CLIPS. IF THE HARNESS WIRES DO SHOW DAMAGE, THE DEALERS WILL INSTALL A NEW HARNESS WITH PREINSTALLED INTEGRAL HEAT PROTECTION.
Notes: OWNER NOTIFICATION BEGAN FEBRUARY 7, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A HOSE WAS MIS-MANUFACTURED AND COULD WEAKEN OVER TIME, WHICH COULD RESULT IN LEAKAGE OF THE AUTOMATIC TRANSMISSION FLUID.
Consequence: FLUID LEAKAGE FROM THE COOLER HOSES CAN CAUSE TRANSAXLE DRIVEABILITY PROBLEMS AND SMOKE IF THE OIL CONTACTS THE FRONT EXHAUST PIPE.
Remedy: DEALERS WILL REPLACE THE HOSE ASSEMBLY FOR THE AUTOMATIC TRANSMISSION OIL COOLER. OWNER NOTIFICATION MAILING WILL BE PHASED OVER A FIVE-MONTH PERIOD STARTING MARCH 26, THROUGH JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COLUMN SWITCH LEVERS CAN BECOME LOOSE OR BREAK OVER TIME.
Consequence: LOOSENING OR CRACKING OF THE LEVERS CAN CAUSE DIRECTIONAL LAMPS THAT DO NOT SELF-CANCEL OR OPERATE, HEAD LAMPS THAT DO NOT TURN OFF, WINDSHIELD WASHERS THAT OPERATE CONTINUOUSLY AND/OR WINDSHIELD WIPERS THAT DO NOT OPERATE.
Remedy: DEALERS WILL INSTALL A REDESIGNED SWITCH.
Notes: MITSUBISHI RECALL NO. SR-99-003. OWNER NOTIFICATION BEGAN DECEMBER 13, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

12/21/2017 · Electrical system
I AM DISABLED BY MY OWN FACTORY ALARM. THE CAR WILL NOT START BECAUSE MY ECU WAS DEFECTIVE AND I REPLACED IT WITH A USED ONE AND TOOK IT TO THE DEALER TO PROGRAM MY KEY TO THE REPLACEMENT ECU AND THE KEY STILL DOESN'T WORK EVEN THOUGH I AM GETTING A P1610 TROUBLE CODE FOR IMMOBILIZER MALFUNCTION WHICH IS DUE TO AN ECU NOT RECOGNIZING THE KEY. EVEN THE DEA…

05/22/2015 · Airbags · crash
TL* THE CONTACT OWNED A 2000 MITSUBISHI GALANT. WHILE DRIVING 25 MPH, ANOTHER VEHICLE EQUIPPED WITH A CRASH BAR CRASHED HEAD ON INTO THE CONTACT'S VEHICLE AT 50 MPH. THE CONTACT'S AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK INQUIRES AND A HERNIATED DISK DISPLACER. MEDICAL ATTENTION WAS RECEIVED. A POLICE REPORT WAS FILED, BUT WAS NOT REPORTED ACCU…

10/08/2014 · Engine
TL* THE CONTACT OWNS A 2000 MITSUBISHI GALANT. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 230,000.

04/09/2013 · Engine
TL* THE CONTACT OWNS A 2000 MITSUBISHI GALANT. THE CONTACT STATED THAT THE TEMPERATURE GAUGE NEEDLE WOULD FLUCTUATE CONTINUOUSLY. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS, WHO STATED THAT THE FAILURE WAS RELATED TO THE RADIATOR, WHICH WOULD NEED TO BE REPLACED. THE VEHICLE WAS NO…

10/16/2010 · Electrical system
I OWN A 2000 MITSUBISHI GALANT. FOR THE LAST TWO MONTHS, I HAVE BEEN IN AND OUT OF THE REPAIR SHOP. I AM NOT A MECHANIC; HOWEVER, I KNOW THAT THERE IS A PROBLEM IN THE ELECTRICAL SYSTEM. WHILE DRIVING, THE CAR WILL JUST STOP IN THE MIDDLE OF THE ROAD. WHEN IT OCCURS, IT WILL NOT START AND HAS TO BE TOWED IN. THE FIRST TWO TIMES, THE MECHANIC REPLACED T…

08/26/2010 · Electrical system
TL* THE CONTACT OWNS A 2000 MITSUBISHI GALANT. THE CONTACT WAS TRAVELING 55 MPH WHEN THE VEHICLE STALLED WITH THE ILLUMINATION OF THE ENTIRE DASHBOARD. THE VEHICLE WAS INSPECTED BY THE CONTACTS PERSONAL MECHANIC WHO ADVISED THAT THE BATTERY CABLE WIRING HARNESS FAILED AND CAUSED THE VEHICLE TO STALL. THE CONTACT LOCATED NHTSA CAMPAIGN ID NUMBER: 99V333001 (…

07/27/2010 · Electrical system
MATCHING RECALL MITSUBISHI NOTICE SR-99-003 AND NHTSA 99V305001, OUR GALANT HAS THE BUSTED TURN SIGNAL PROBLEM. MITSUBISHI CLAIMS OUR VIN IS OUTSIDE THE RANGE OF DEFECTIVE UNITS. OBVIOUSLY, THAT'S NOT THE CASE, BUT THEY'RE NOT PAYING. *TR

07/02/2010 · Vehicle Speed Control · crash
TL*THE CONTACT OWNS A 2000 MITSUBISHI GALANT. THE CONTACT STATED THAT ON JUNE 25, 2010, THE THROTTLE BECAME STUCK CAUSING HIM TO CRASH INTO A FUEL PUMP AT A GASOLINE STATION. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DAMAGED BUT NOT DESTROYED. THE CONTACT STATED, THAT WAS THE FIRST TIME HE EXPERIENCED THAT TYPE OF FAILURE. THE CONTA…