2004 Mitsubishi Montero Sport recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. ON CERTAIN SPORT UTILITY VEHICLES, THE VEHICLE CAPACITY WEIGHTS AS STATED ON THE TIRE AND LOADING INFORMATION LABEL ARE IN ERROR.
What could happen: THIS INFORMATION COULD POTENTIALLY RESULT IN CONSUMERS LOADING THEIR VEHICLES BEYOND THE GROSS VEHICLE WEIGHT RATING (GVWR).
The fix: OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. THE RECALL BEGAN ON APRIL 14, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 MONTERO SPORT.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 04V095000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-222-0037.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: ON CERTAIN SPORT UTILITY VEHICLES, THE VEHICLE CAPACITY WEIGHTS AS STATED ON THE TIRE AND LOADING INFORMATION LABEL ARE IN ERROR.
Consequence: THIS INFORMATION COULD POTENTIALLY RESULT IN CONSUMERS LOADING THEIR VEHICLES BEYOND THE GROSS VEHICLE WEIGHT RATING (GVWR).
Remedy: OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. THE RECALL BEGAN ON APRIL 14, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- 2004 Mitsubishi Montero Sport owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (2), Engine (1), Transmission / drivetrain (1), Airbags (1), Seat belts (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (5)
11/19/2015 · Fuel system
FILL SUV WITH GAS AND IT ALL LEAKED OUT UNDER THE SUV.
10/21/2015 · Fuel system
TL* THE CONTACT OWNS A 2004 MITSUBISHI MONTERO SPORT. THE CONTACT DETECTED THE ODOR OF FUEL IN THE VEHICLE. THE CONTACT STATED THAT THE FAILURE BECAME PROGRESSIVELY WORSE OVER TIME. AFTER FULLY REFUELING THE VEHICLE, IT BEGAN TO LEAK FUEL AT APPROXIMATELTY FOUR DROPS PER SECOND. THE CONTACT ALSO STATED THAT THE VEHICLE LEAKED FUEL WHEN PARKED ON INCLINES. T…
10/01/2014 · Engine
HEAT GAUGE IS FAULTY AND IT WILL BLOW HOT HEAT ONLY OUT OF DRIVER SIDE VENTS AND BLOWS COLD OUT OF THE REST OF THE VENTS. HEAT GAUGE SAYS ITS RUNNING FINE BUT IT IS REALLY OVERHEATING TO THE BOILING POINT. I AM NOT SURE HOW LONG IT HAS HAD THIS PROBLEM AS I JUST BOUGHT IT 2 WEEKS AGO AND HAVE HAD NO USE FOR THE HEAT TILL NOW AND NEVER DROVE IT FAR ENOUGH TI…
07/07/2009 · Transmission / drivetrain
2004 MITSUBISHI MONTERO SPORT I PURCHASED THE VEHICLE FROM DRIVETIME AND THE SERVICE ENGINE LIGHT CAME ON IMMEDIATELY. IT WENT OFF AFTER I TURNED IT OFF. 2 DAYS LATER THE A/T TEMP LIGHT CAME ON. THE 4H LIGHT CAME ON AND THE ANTI LOCK BRAKE LIGHT CAME ON. I CALLED THE WARRANTY COMPANY AND I WAS SENT TO A MECHANIC WHO REMOVED ALL THE ELECTRIC CONNEC…
01/05/2006 · Airbags · crash
DT*: THE CONTACT STATED WHILE DRIVING ON SLIPPERY ROADS THE CONSUMER HIT A PUDDLE AND ROLLED OVER A FENCE INTO A WATER RESERVE. UPON IMPACT, BOTH FRONTAL AIRBAGS FAILED TO DEPLOY AND THE DRIVER'S SEAT BELT FAILED. THE SEAT BELT CAME UNLATCHED WHILE THE VEHICLE ROLLED OVER THE FENCE. THE SEAT BELT WAS ABLE TO LATCH AFTER THE ACCIDENT. THE CONTACT SUSTAI…