1997 Mitsubishi Montero recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Unknown Or Other
What's wrong, in plain English: A vehicle part that may fail. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.
What could happen: IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE.
The fix: DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 MONTERO.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 98V205000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: UNKNOWN OR OTHER
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS.
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING.
Notes: OWNER NOTIFICATION BEGAN OCTOBER 16, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER.
What could happen: BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP.
The fix: DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRECT. IF THERE IS EVIDENCE OF BRAKE LINE WEAR, THE BRAKE LINE WILL BE REPLACED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 MONTERO.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 98V220000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER.
Consequence: BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP.
Remedy: DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRECT. IF THERE IS EVIDENCE OF BRAKE LINE WEAR, THE BRAKE LINE WILL BE REPLACED.
Notes: OWNER NOTIFICATION BEGAN OCTOBER 23, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1997 Mitsubishi Montero owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (35), Brakes (16), Hydraulic (16), Electrical system (10), Suspension (8).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
05/19/2016 · Suspension
TL* THE CONTACT OWNS A 1997 MITSUBISHI MONTERO SPORT. WHILE DRIVING BETWEEN 55 AND 65 MPH, THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BALL JOINTS, WHEEL BEARINGS, TRANSMISSION MOUNT, UNIVERSAL BOLT, AND TIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED.…
04/15/2015 · Engine
VEHICLE LOST POWER STEERING AND STALLED. CRANKSHAFT PULLEY BOLT FELL OUT AND HARMONIC BALANCER FELL OFF.CAUSING LOSS OF CONTROL AND LIFE THREATENING SITUATION. *TR
03/13/2015 · Engine
COMMON PROBLEM WITH THESE, CRANK SHAFT PULLEY BOLT DEFECTIVE SHOULD HAVE RECALLED ALL OF THEM. *TR
10/28/2014 · Steering
CRANKSHAFT PULLEY BOLT CAME LOOSE CAUSING LOSS OF STEERING. HAD TO STEER VERY HARD MANUALLY TO PARK CAR. DANGEROUS SITUATION. *TR
06/09/2014 · Electrical system · fire
ON 5/31/14, MY 1997 MITSUBISHI MONTERO WAS PARKED IN MY DRIVEWAY. WHEN I WENT TO GET INTO THE VEHICLE, I NOTICED A LARGE BURN IN THE BACK OF THE DRIVER'S SIDE SEAT. AFTER CALLING MITSUBISHI, THE FIRE DEPARTMENT CAME SINCE IT WAS STILL SMOLDERING AND DISCONNECTED THE BATTERY. THEY BELIEVED IT TO BE AN ELECTRICAL SHORT. AFTER MANY FOLLOW-UP CALLS TO MITSUBISH…
04/16/2011 · Engine
1997 MITSUBISH MONTERO 3.5 LITER AUTOMATIC- CRANK SHAFT BOLT HAS COME OUT ON 5 SEPARATE OCCASIONS AND HAS COST OVER $3000 TO HAVE IT REPLACED. THE INSIDE OF THE CRANKSHAFT WHERE THE BOLT GOES IS COMPLETELY STRIPPED TO THE POINT I NOW HAVE TO REPLACE THE ENGINE. THIS IS NOT AN ISOLATED ISSUE AS THIS APPEARS TO BE AN INHERENT PROBLEM WITH ALL YEARS OF MONT…
02/26/2011 · Engine
CRANKSHAFT PULLEY PIN/BOLT GETS SHEARED OFF. DASH LIGHTS COME ON AND VEHICLE POWER STEERING STOPS WORKING AS THE PUMP IS NOT TURNING BECAUSE THE PROBLEM AFFECT THE ENTIRE PULLEY SYSTEM. IT ALSO AFFECTS THE TIMING GEAR/BELT/HARMONIC BALANCER. THIS IS THE 3RD TIME IN AS MANY YEARS THIS HAS HAPPENED. THIS IS THE 2ND MECHANIC WHO HAS TOLD ME THAT IT'S AN ENGINE…
04/16/2010 · Fuel system · fire
THE VEHICLE WAS PARKED AND IDLING. I WAS IN THE DRIVER'S SEAT WHEN A FIRE BROKE OUT AND THE FLAMES CAUSED ME SEVERE BURNS TO MY BODY. I WAS NEARLY ASPHYXIATED. THE CAR WAS A TOTAL LOSS. *TR