2003 Mitsubishi Outlander recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN SPORT UTILITY VEHICLES, DURING EXTREMELY LOW TEMPERATURE CONDITIONS, ICE CAN BUILD UP INSIDE THE ENGINE THROTTLE VALVE. THIS ICE BUILD-UP COULD CAUSE THE ACCELERATOR PEDAL TO STICK OR NOT TO RETURN TO IDLE AFTER ACCELERATING.
Consequence: FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPROGRAM THE ENGINE CONTROL COMPUTER TO ELIMINATE THIS CONDITION. OWNER NOTIFICATION BEGAN ON JANUARY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Notes: MITSUBISHI RECALL BULLETIN NO. SR-03-001. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: TRAILER HITCHES
Summary: CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
Consequence: OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
Remedy: OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Notes: MITSUBISHI RECALL NO. SR-04-004. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Summary: CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER'S MANUAL DOES NOT CONTAIN A STEP-BY-STEP DESCRIPTION FOR HEADREST ADJUSTMENT WHEN INSTALLING A CHILD RESTRAINT SYSTEM (CRS) TETHER STRAP.
Consequence: IF THE TETHER STRAP IS IMPROPERLY INSTALLED TO THE TETHER ANCHOR, THE CHILD SAFETY SEAT MAY NOT BE SUFFICIENT RESTRAINED. IN THE EVENT OF A CRASH, THE CHILD COULD BE INJURED.
Remedy: A LETTER OUTLINING THE PROBLEM WILL BE SENT TO OWNERS ALONG WITH A STICKER CONTAINING THE CORRECT INSTRUCTIONS AS WELL AS INSTRUCTIONS ON WHERE TO AFFIX THE STICKER IN THE OWNER'S MANUAL. THE RECALL BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Notes: MITSUBISHI RECALL NO. SR-04-002. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence: A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EQUIPMENT:OTHER:LABELS
Summary: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Notes: THE MANUFACTURER'S PETITION WHICH REQUESTED THAT NHTSA DETERMINE THIS FMVSS NONCOMPLIANCE DOES NOT CREATE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY WAS PARTIALLY DENIED ON JANUARY 26, 2005. THEREFORE, THIS MANUFACTURER IS OBLIGATED TO CONDUCT AN OWNER NOTIFICATION AND REMEDY CAMPAIGN. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

Component: ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
Summary: ON CERTAIN SPORT UTILITY VEHICLES, WATER COULD ENTER THE FRONT FLOORBOARD AREA FROM OPENINGS IN THE SIDE SILL OR UPPER DASH AREA. THIS WATER COULD COLLECT UNDER THE SEAT AND CAUSE ELECTRICAL CORROSION TO OCCUR IN THE HARNESS CONNECTORS THAT CONTAIN THE WIRING FOR THE SEAT BELT PRE-TENSIONER, SIDE AIR BAG IMPACT SENSOR, AND STOP LAMPS.
Consequence: ELECTRICAL CORROSION OF THE HARNESS COULD CAUSE THE SEAT BELT PRE-TENSIONER TO MALFUNCTION, THE SIDE AIR BAG NOT TO DEPLOY AND/OR THE BRAKE LAMPS NOT TO ILLUMINATE OR TO FALSELY ILLUMINATE.
Remedy: DEALERS WILL INSPECT THE SIDE SILLS AND DASH PANEL FOR OPENINGS THAT MAY ALLOW WATER LEAKAGE INTO THE VEHICLE CABIN. IN ADDITION TO SEALING ANY OPENINGS THAT MAY BE FOUND, THE WIRING CONNECTORS WILL BE INSPECTED FOR SIGNS OF ELECTRICAL CORROSION. THE FLOOR HARNESS WILL BE REPLACED IF IT HAS ANY SIGNS OF WATER DAMAGE OR ELECTRICAL CORROSION. OWNER NOTIFICATION BEGAN JUNE 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

08/27/2024 · Suspension
The contact owns a 2003 Mitsubishi Outlander. The contact stated while driving at approximately 25 MPH, the vehicle came to an immediate stop and did not return to normal operation. The contact noticed that the front control arm had detached. No warning light was illuminated. The contact researched and became aware of NHTSA Campaign Number: 16V458000 (Suspe…

05/02/2023 · Unknown Or Other
HVAC temperature control knob is hard to turn, it broke off.

12/04/2019 · Suspension
REAR CONTROL ARMS ARE RUSTED THROUGH, THERE WAS A RECALL FOR THE FRONT AND HAD THE REPAIRS DONE. THE FRONT CONTROL ARM RECALL WAS DUE TO POOR RUST PROOFING DURING MANUFACTURING. THE REAR HAS THE SAME PROBLEM. CANNOT REALIGN REAR WHEELS AND REAR SWAY BAR BRACKET BROKE FREE ENTIRELY. VEHICLE IS NOW STATIONARY AS IT CANNOT BE DRIVEN.

11/04/2019 · Suspension
CAR TAKEN TO DEALERSHIP, ANDERSON MITSUBISHI, 8162790354), JANUARY 2017, FOR NHTSA RECALL 16V458. CROSSMEMBER NOT REPLACED OR RUST TREATED. CROSSMEMBER FAILED 4-20-2019. REPAIRED AT MY EXPENSE $2161.70. MADE CLAIM FOR REIMBURSEMENT THROUGH MITSUBISHI DEALER AND MITSUBISHI OF NORTH AMERICA. HAVE A MITSUBISHI FILE NUMBER [XXX]. MITSUBISHI OF NA HAS VERBA…

06/24/2019 · Airbags · crash
TL* THE CONTACT OWNED A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED WHILE ATTEMPTING TO AVOID COLLIDING WITH A DEER. DURING THE CRASH, THE VEHICLE HAD ROLLED OVER AND THE DRIVER WAS KNOCKED UNCONSCIOUS. THE DRIVER SUSTAINED HEAD AND NECK INJURIES, A FRACTURED LEFT…

04/01/2019 · Unknown Or Other
THE ISSUE BEGAN IN 2004 WHEN MY VEHICLE WAS 1 YEAR OLD. THE TEMPERATURE CONTROL KNOB BECAME FROZEN AND YOU COULD NOT TURN IT FROM HEAT TO AIR CONDITIONING OR THE OTHER WAY. I SPENT $23,000 ON THIS CAR AND YOU COULD NOT TURN FROM AIR CONDITIONING TO HEAT AT WILL ONLY A MECHANIC CAN MANUALLY TURN IT UNDERNEATH THE VEHICLE AND THEN ONLY PUT IT ON HOT OR COLD…

04/01/2019 · Unknown Or Other
SINCE THE SECOND YEAR SINCE I'VE OWNED THIS CAR THE TEMPERATURE CONTROL KNOB HAS BEEN FROZEN. THE ONLY WAY YOU CAN TURN THE KNOB IS TO HAVE A MECHANIC MANUALLY TURN THE KNOB UNDERNEATH THE VEHICLE. MITSUBISHI MOTORS ADMITTED THIS WAS A DESIGN FLAW IN 2002 TO 2007 MITSUBISHI LANCERS AND OUTLANDERS. I HAVE CALLED MITSUBISHI MANY TIMES AND SENT LETTERS…

11/13/2018 · Engine
CAR HAS BEEN OWNED FOR 10+ YEARS AND HAS BEEN MAINTAINED VERY WELL. GAS MILEAGE HAS DROPPED SINCE 2014. CAR THREW A P420 CODE IN THE YEARS AFTER. CATALYTIC CONVERTER HAS BEEN REPLACED FOUR TIMES IN A YEAR. OXYGEN SENSOR HAS BEEN REPLACED AND NEW EXHAUST HAS BEEN INSTALLED. WE HAVE NOW SEEN THE EXHAUST MANIFOLD HAS A CRACK IN IT. THIS APPEARS TO BE A MANUFAC…