2010 Tesla Roadster2 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. 0 AND 2.5 VEHICLES EQUIPPED WITH A 12V AUXILIARY CABLE. THE 12V AUXILIARY CABLE FOR THE LOW VOLTAGE BACK UP POWER SYSTEM MAY BE IMPROPERLY ROUTED. IF THE WIRE IS IMPROPERLY ROUTED, AND TRAPPED AGAINST THE WHEEL WELL COVER, THE WIRE MAY ABRADE AGAINST THE EDGE OF THE CARBON FIBER ARMATURE AND, OVER TIME, EXPOSE THE WIRE. CONTACT BETWEEN THE BARE WIRE AND CARBON FIBER MAY CAUSE A SHORT-CIRCUIT LEADING TO POSSIBLE ELEC…
What could happen: SHORT CIRCUIT AND ELECTRICAL ARCING COULD LEAD TO A FIRE IN THE RIGHT FRONT HEADLAMP AREA.
The fix: TESLA MOTORS WILL CHECK THE ROUTING OF THE 12V AUXILIARY CABLE AND INSTALL A PROTECTIVE SLEEVE OVER THE WIRE FREE OF CHARGE. THIS WILL PREVENT MISROUTING AND PINCHING BY THE WHEEL WELL COVER. THE SAFETY RECALL BEGAN ON OCTOBER 31, 2010. OWNERS MAY CONTACT TESLA CUSTOMER SERVICE AT 877-888-3752.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2010 ROADSTER2.
- Book a repair at any authorized Tesla dealer. Quote NHTSA campaign 10V458000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Summary: TESLA IS RECALLING CERTAIN MODEL YEAR 2010 ROADSTER 2.0 AND 2.5 VEHICLES EQUIPPED WITH A 12V AUXILIARY CABLE. THE 12V AUXILIARY CABLE FOR THE LOW VOLTAGE BACK UP POWER SYSTEM MAY BE IMPROPERLY ROUTED. IF THE WIRE IS IMPROPERLY ROUTED, AND TRAPPED AGAINST THE WHEEL WELL COVER, THE WIRE MAY ABRADE AGAINST THE EDGE OF THE CARBON FIBER ARMATURE AND, OVER TIME, EXPOSE THE WIRE. CONTACT BETWEEN THE BARE WIRE AND CARBON FIBER MAY CAUSE A SHORT-CIRCUIT LEADING TO POSSIBLE ELECTRICAL ARCHING.
Consequence: SHORT CIRCUIT AND ELECTRICAL ARCING COULD LEAD TO A FIRE IN THE RIGHT FRONT HEADLAMP AREA.
Remedy: TESLA MOTORS WILL CHECK THE ROUTING OF THE 12V AUXILIARY CABLE AND INSTALL A PROTECTIVE SLEEVE OVER THE WIRE FREE OF CHARGE. THIS WILL PREVENT MISROUTING AND PINCHING BY THE WHEEL WELL COVER. THE SAFETY RECALL BEGAN ON OCTOBER 31, 2010. OWNERS MAY CONTACT TESLA CUSTOMER SERVICE AT 877-888-3752.
Notes: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2010 Tesla Roadster2 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (1), Electrical system (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (1)
09/15/2011 · Transmission / drivetrain
WHILE DRIVING AT APPROXIMATELY 30MPH, MY CAR EXPERIENCED "DRIVE LOSS", WHICH MEANS THE POWER TRAIN WAS SHUT DOWN SO THE CAR COULD ONLY COAST TO A STOP. THIS HAPPENED WITH NO WARNING. AS THE POWER WAS SHUT DOWN, THE ON BOARD SCREEN STATED "POWER TRAIN SHUT DOWN" OR A SIMILAR MESSAGE. I WAS NOT IN A DANGEROUS SITUATION AT THE TIME, SO I WAS ABLE TO STOP WITH…