1999 Toyota Avalon recalls & complaints

Component: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER/NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA DISTRIBUTOR AT 1-800-301-6859. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Summary: EQUIPMENT DESCRIPTION: AFTERMARKET THEFT DETERRENT SYSTEMS USED ON 1998-1998 TOYOTA RAV4, AVALON, AND SIENNA MODEL VEHICLES DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN "OPEN CIRCUIT" CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Notes: OWNER NOTIFICATION IS BEING HANDLED BY SOUTHEAST TOYOTA DISTRIBUTORS. OWNER NOTIFICATION BEGAN NOVEMBER 3, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA DISTRIBUTOR AT 1-800-301-6859. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

12/05/2015 · Steering
THE CAR STEERING IS HARD TO TURN UNTIL IT WARMS UP. I TOOK THE STEERING TO THE REPAIR SHOP FOR FLUSHING 12/3/2015 BUT THIS HAS NOT SOLVED THE PROBLEM. THE STEERING CONTINUES TO BE STIFF/HARD WHEN TURNING. I DON'T KNOW WHAT THE PROBLEM IS. IT IS THE ONLY CAR MY FAMILY USES AND THIS IS INCREASING MAKING THE CAR UNSAFE TO DRIVE.

04/28/2015 · Electrical system
WHILE THE VEHICLE WAS AT A REPAIR FACILITY FOR AN UNRELATED ISSUE THE MECHANIC NOTICED AN ODOR OF BURNING PLASTIC FROM THE DRIVERS SIDE DOOR PANEL. UPON EXAMINATION THE MECHANIC FOUND THE FRONT PASSENGER WINDOW SWITCH ON THE DRIVERS MASTER WINDOW CONTROL PANEL HAD MELTED AND A HOLE FUSED THROUGH THE SIDE OF THE SWITCH CONTROL UNIT. THE MECHANIC REMOVED TH…

11/15/2014 · Visibility (wipers / glass)
ON OR ABOUT THE DATE BELOW, I WAS TRAVELING ON THE I-405 N FREEWAY IN LOS ANGELES WHEN MY SUNROOF GLASS PANEL FLEW OFF OF MY CAR. THE SUNROOF WAS CLOSED AT THE TIME, BUT I HAD NOTICED INCREASING WIND NOISE OVER THE LAST 12 MONTHS OR SO. AFTER CONDUCTING SOME ONLINE RESEARCH, IT APPEARS THAT OTHER SUNROOFS (E.G., THE WEBASTO MODELS 600/700 AND 900) THAT ALSO…

05/02/2014 · Airbags · crash
WAS DRIVING SOUND ON GREGORY RD AND ANOTHER CAR WAS TRAVELING NORTH SHE CAME INTO MY LANE AT ABOUT 40 MPH AND HIT ME HEAD ON MY AIRBAG NEW DEPLOYED AND MY SEATBELT DID NOT HOLD I HAVE A BRUISE ACROSS MY CHEST FROM STEERING WHEEL AND BUMPS ON MY HEAD. *TR

03/20/2014 · Vehicle Speed Control
DRIVING MY DAUGHTER TO SCHOOL ABOUT THE 17TH OF DECEMBER 2013, I ATTEMPTED TO BRAKE THE CAR TO A STOP. INSTEAD THE CAR LURCHED FORWARD SUDDENLY OUT OF CONTROL AND MOUNTED THE SIDEWALK. IT TRAVELED ABOUT 20 FEET BEFORE I WAS ABLE TO BRAKE IT TO A COMPLETE STOP. THERE WAS NO OBJECT OR PERSON IN THE PATH OF THE CAR AND NOBODY WAS INJURED. THIS IS THE THIRD S…

04/29/2011 · Electrical system
TL*THE DRIVER OWNS A 1999 TOYOTA AVALON. THE CONTACT STATED THE VEHICLE EXPERIENCED A RECURRING FAILURE IN WHICH THE CHECK ENGINE LIGHT WOULD INTERMITTENTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THE ALARM SYSTEM WOULD INTERMITTENTLY TURN ON INVOLUNTARILY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THE VEHI…

08/10/2010 · Electrical system · fire
THERE WAS NO SPECIFIC "EVENT" CAR JUST SPONTANEOUSLY CAUGHT FIRE. CAR WAS PARKED, DRIVER AWAY FROM THE CAR, WHEN DRIVER RETURNED AND GOT INTO CAR NOTICED A SMELL, THOUGHT IT WAS COMING FROM OUTSIDE, PUT THE WINDOW UP AND SMELL WAS STRONGER. LOOKED DOWN AND FLAMES WERE SHOOTING OUT FROM UNDER THE RADIO. FIRE DEPARTMENT CALLED, FIRE EXTINGUISHED. *TR

04/02/2010 · Electrical system
ON AUGUST 9, 2009, MY WIFE WAS DRIVING HER AVALON WITH OUR 8-YEAR-OLD DAUGHTER IN IT, TO GRAB A BITE TO EAT IN WALNUT CREEK, CA. WHEN MY WIFE TRIED TO STOP THE CAR AND TURNED OFF THE ENGINE, THE CAR WAS SHAKING AND THE ENGINE KEPT RUNNING EVEN THOUGH THE KEY WAS OUT OF THE IGNITION. SINCE SHE COULD NOT TURN OFF THE ENGINE, SHE DECIDED TO DRIVE BACK HOME THA…