2001 Toyota Highlander recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
What could happen: THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2001 HIGHLANDER.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 01V228000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Summary: VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
Consequence: THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE…
What could happen: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
The fix: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2001 HIGHLANDER.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 02V208000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Summary: ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Consequence: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
What could happen: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
The fix: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2001 HIGHLANDER.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 04V181000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Notes: TOYOTA RECALL NO. SSC 40B. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2001 Toyota Highlander owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Visibility (wipers / glass) (26), Brakes (20), Engine (19), Hydraulic (16), Vehicle Speed Control (15).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
05/12/2020 · Wheels / tires
MY FRONT TIRES, (FROM A SET OF FOUR), HAVE PARTS OF THE TREAD SEPARATING FROM THE TIRE BODY. THE RUBBER UNDER THE MISSING PIECES OF TREAD HAS A TEXTURE LIKE POPCORN. THE INNER SURFACE OF THE RUBBER IS SHINY AND SMOOTH. *DT IT IS NOT FROM GOUGING, FORCE, OR ABUSE TO THE TIRES. IT IS AS IF THE MANUFACTURING PROCESS USED TWO DIFFERENT BATCHES OF RUBBER THAT…
03/12/2018 · Body / structure
SUNROOF GLASS BLEW OFF OF THE VEHICLE ON THE HIGHWAY YESTERDAY. I SEE NUMEROUS REPORTS OF THIS ON THE INTERNET. WAS THERE EVER A TSB OR RECALL FOR THIS ISSUE FROM TOYOTA? DANGEROUS AND SCARY, HAPPENED IN TRAFFIC.
09/12/2017 · Steering
I AM SOLE OWNER OF THIS VEHICLE SINCE BOUGHT IT NEW AND WELL MAINTAIN IT. DASHBOARD AND STEERING WHEEL ARE PEELING AND GOOEY. TOYOTA SERVICE DEALERSHIP TOLD ME NOTHING THEY CAN DO ABOUT IT AND ASKED ME TO CALL TOYOTA. I CALLED AND FILED A COMPLAINT NO. 1709121290 WITH TOYOTA. THEY TOLD ME THEY HAD RECALLS ON OTHER MODELS BUT NOT THIS ONE SO IT SEEMS THI…
05/19/2017 · Body / structure · crash
ON 11/17/2015 I HIT A PARKING ISLAND IN AN UNLIT PARKING LOT. WHEN I TRIED TO STOP, MY BRAKES FAILED. THIS CAUSED ME TO LOSE CONTROL OF THE VEHICLE AND IT HIT 2 PARKED CARS AND A TREE. I HAVE LOST WAGES AND LIVE IN PAIN EVERY DAY DUE TO INJURIES FROM THIS ACCIDENT.
05/27/2016 · Visibility (wipers / glass)
DRIVER SIDE VISOR WILL NOT STAY UP. IT DROOPS APPROXIMATELY 60 DEGREES WHEN LOWER TO BLOCK SUN.
08/04/2015 · Vehicle Speed Control · crash
TL* THE CONTACT OWNS A 2001 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE ATTEMPTING TO PARK, THE VEHICLE SUDDENLY ACCELERATED INDEPENDENTLY AND CRASHED INTO A PARKED VEHICLE. THE CONTACT SHIFTED THE VEHICLE INTO REVERSE AND CRASHED INTO THE REAR OF A SECOND VEHICLE. THE POLICE WAS CONTACTED, BUT A REPORT WAS NOT FILED. THE DRIVER SUSTAINED WHIPLASH AND NECK…
05/08/2015 · Body / structure
FAULTY STOP LIGHTS, AFTER SEVERAL ATTEMPTS TO REPAIR THE STOP LIGHTS. THE PROBLEM REMAINS UNSOLVED AND KEEPS COMING BACK ON BOTH TAIL LIGHTS. WHAT'S WRONG TOYOTA?
01/27/2015 · Airbags
TL* THE CONTACT OWNS A 2001 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE SPIRAL CABLE NEEDED TO BE REPLACED; HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.