1999 Volkswagen Golf recalls & complaints

Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Consequence: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES AND DOUBLE-LAYER FUEL TANKS, TENSION ON THE FUEL SUPPLY LINE MAY CAUSE THE FUEL PUMP SUPPLY NIPPLE TO CRACK WHICH COULD RESULT IN A LEAK.
Consequence: LEAKING FUEL, IN THE PRESENCE OF AN IGNITION SOURCE, MAY CAUSE A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL SUPPLY LINE FOR TENSION, AND INSPECT THE FUEL PUMP SUPPLY NIPPLE FOR CRACKING. IF NECESSARY THE FUEL LINE AND THE FUEL PUMP WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Notes: VOLKSWAGEN RECALL NO. UU. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Notes: VOLKSWAGEN RECALL NO. N4. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EQUIPMENT:OTHER:LABELS
Summary: CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALLY UNDER INFLATED TIRES PUTS THE CONSUMER AT RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
Notes: VW RECALL NO. WN. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: STRUCTURE:FRAME AND MEMBERS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Notes: OWNER NOTIFICATION BEGAN FEBRUARY 15, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VWOA AT 1-877-270-4178. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

12/13/2016 · Visibility (wipers / glass)
WHITE METAL USED IN FRONT AND READ WINDSHIELD WIPERS AND ALSO REAR HATCH DOOR LATCH FLAKE APART AND CRUMBLE MAKING WIPERS AND LATCH UNUSABLE. REPLACED FRONT WIPER ASSEMBLY JUNE 2012, REAR WIPER DOES NOT WORK, SAME WITH REAR DOOR LATCH. FRONT WIPERS STOPPED WORKING SUDDENLY WHILE IN A SUMMER DOWNPOUR CAUSING A MAJOR SAFETY PROBLEM.

09/08/2015 · Seat belts
THIS STARTED TO OCCUR ABOUT 2009, ABOUT 6 YEARS AGO. WHEN I PUSHED UP THE REAR SEATS, I DISCOVERED THAT THE CENTER SEAT BELT WAS TIGHT AND WOULD NOT RELEASE. I COULDN'T EVEN PUSH THE REAR SEAT BACK DOWN BECAUSE THE SEAT BELT WAS SO EXTREMELY TIGHT. WITHIN A YEAR OR TWO LATER, ALL OF THE REAR SEAT BELTS LOCKED UP. THE REAR SEATS ARE NOW UNSAFE FOR PASSEN…

09/08/2015 · Electrical system · fire
INSTRUMENT CLUSTER FIRE IN 1999 VW GOLF TDI: 2003-01-14, MILEAGE 88290, LIGHTS AND GAUGES ON INSTRUMENT CLUSTER WERE ACTING FLAKY AND NOT WORKING PROPERLY. SOME LIGHTS WERE DIM AND SOME WERE BURNT OUT. 2003-02-05, I BOUGHT NEW INSTRUMENT CLUSTER. PLAN WAS TO HAVE DEALERSHIP REPLACE FAULTY ONE WITH NEW ONE ON 2003-02-10. A FEW DAYS AFTER I BOUGHT NEW…

09/08/2015 · Visibility (wipers / glass)
WINDOW REGULATOR SWITCHES AND INTERIOR LIGHTS STARTED TO MALFUNCTION EARLY IN THE LIFE OF THE CAR, STARTING ABOUT 2003. MY PASSENGER WINDOW FELL INTO THE DOOR ONCE, AND THE SAME HAPPENED FOR MY DRIVER SIDE WINDOW TWICE. THE WINDOW SWITCHES ARE FLAKY AND REQUIRE INTENSE CONCENTRATION TO TAP THEM JUST RIGHT TO MAKE THE WINDOW GO IN THE DIRECTION THAT YOU WA…

01/28/2009 · Fuel system
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VALVE IN THE FUEL CAUSES THE VEHICLE TO STALL WITHOUT WARNING. THE VALVE BECOMES CLOGGED WITH THE FUEL. HE HAS RESEARCHED SEVERAL COMPLAINTS REGARDING THIS FAILURE AND STATED THAT VOLKSWAGEN IS AWARE, BUT DOES NOTHING TO RECTIFY THE ISSUE. ON SEPARATE OCCASIONS, THE CONTACT HAS BEEN…

12/18/2007 · Engine
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN GOLF. THE VEHICLE HAS A RECALL NOTICE FOR THE O RING DEFECT. THE DEFECT CAUSES THE VEHICLE TO OVERHEAT, RESULTING IN ENGINE FAILURE. THE CONTACT STATED THAT THE VEHICLE RECEIVED THE 44K TREATMENT TO RECTIFY THE FAILURE AND NOW THE ENTIRE EXHAUST SYSTEM NEEDS TO BE REPLACED. THE MANUFACTURER HAS NOT BEEN NOTIFIED. T…

11/22/2007 · Visibility (wipers / glass)
WINDSHIELD WIPER FAILURE. *TR

09/21/2007 · Wheels / tires
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN GOLF. THE VEHICLE HAS DOUGLAS & LOMASON (19570R14) TIRES. WHILE DRIVING 65 MPH, THE CONTACT HEARD A LOUD NOISE COMING FROM THE VEHICLE. HE PULLED OVER, NOTICED A FLAT TIRE, AND REPLACED IT WITH A SPARE. THE DEALER STATED THAT THE CASE SEPARATED. THE FAILURE WAS DUPLICATED WITH BOTH FRONT TIRES AND THE REAR DRIVER S…