1997 Volkswagen Passat recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
What could happen: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1997 PASSAT.
- Book a repair at any authorized Volkswagen dealer. Quote NHTSA campaign 09E025000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-626-272-1798.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1997 Volkswagen Passat owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (20), Visibility (wipers / glass) (20), Engine (14), Latches / locks (10), Body / structure (7).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
05/07/2012 · Electrical system · fire
TL* THE CONTACT OWNS A 1997 VOLKSWAGEN PASSAT TDI. THE CONTACT STATED THAT A FIRE ERUPTED SPONTANEOUSLY INSIDE THE DASHBOARD WHICH CAUSED ALL OF THE WIRES TO MELT AND THE WINDSHIELD TO FRACTURE. THE FIRE DEPARTMENT WAS CONTACTED WHO DETERMINED THAT THE FIRE STARTED IN THE AREA WHERE THE IGNITION WAS LOCATED. NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TA…
09/02/2008 · Electrical system
TL*THE CONTACT OWNS A 1997 VOLKSWAGEN PASSAT. WHENEVER THE CONTACT ATTEMPTED TO ACTIVATE THE WINDSHIELD WIPERS OR HEADLIGHTS, THEY FAILED TO TURN ON. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THERE WERE NO WARNINGS PRIOR TO THE FAILURES. THE CURRENT MILEAGE WAS 62,000 AND FAILURE MILEAGE WAS 60,000.
06/09/2008 · Visibility (wipers / glass)
TL*THE CONTACT OWNS A 1997 VOLKSWAGEN PASSAT. WHILE PARKING THE VEHICLE, THE CONTACT HEARD AN UNFAMILIAR NOISE AND THE AIR CONDITIONING BEGAN TO BLOW HOT AIR. HE EXITED THE VEHICLE AND DISCOVERED WATER LEAKING FROM THE UNDERCARRIAGE. HE BELIEVES THAT THE HEATER CORE MAY HAVE FAILED. THE CURRENT AND FAILURE MILEAGES WERE 157,000.
02/27/2008 · Engine
TL*THE CONTACT OWNS A 1997 VOLKSWAGEN PASSAT. THE CONTACT HAS TAKEN HIS VEHICLE TO THE GARAGE AND THE DEALER EIGHT TIMES. THE ENGINE HEAD WAS REPLACED AT 42,000 MILES AND THE TURBO CHARGE IS CURRENTLY FAILING. THE CONTACT STATED THAT THE REPAIRS COST MORE THAN THE ACTUAL PRICE OF THE VEHICLE. THE DEALER STATED THAT THE COMPUTER NEEDED TO BE REPLACED IN…
10/02/2007 · Visibility (wipers / glass)
ON SUNDAY, AUGUST 5TH, 2007, WHILE DRIVING THE CAR WITH MY 7 YEAR OLD SON IN THE BACK SEAT, DENSE, NOXIOUS 'STEAM'/SMOKE BEGAN TO COME OUT OF ALL VENTS AND AROUND THE DASH AREA IN MY WELL-MAINTAINED VOLKSWAGEN. HOT COOLANT ALSO LEAKED INTO THE PASSENGER COMPARTMENT OF MY PASSAT ON THE DRIVER'S SIDE. NOTE THAT THIS OCCURRED WHILE AIR CONDITIONING (A/C) WAS…
09/17/2007 · Electrical system
VEHICLE VOLKSWAGEN 1997 PASSAT GLX - V6 ENGINE. FULL INSTRUMENT CLUSTER - SPEEDOMETER, TACHOMETER, FUEL GAUGE, DIGITAL CLOCK... EVERYTHING ON IT, DOES NOT OPERATE WHEN OUTSIDE TEMPERATURE IS BELOW 50 DEGREES. CAR MUST BE DRIVEN FOR 10MIN., OR ABOUT 8-12 MILES, BEFORE INSTRUMENT CLUSTER RETURNS TO NORMAL FUCTION. CAR IS BEING DRIVEN WITHOUT FUNCTIONING SP…
06/07/2007 · Visibility (wipers / glass)
HEATER CORE FAILED- CLOUDING THE WINDOW TO A DEGREE THAT WE NEARLY HAD AN ACCIDENT BEFORE WE COULD GET THE CAR PULLED OVER.
10/18/2006 · Electrical system
VARIOUS ELECTRONIC COMPONENTS FAILED WHILE DRIVING--WINDSHIELD WIPERS, LIGHTS, DEFROST MOTOR--ON A VERY DARK, RAINY MORNING, CAUSING A DANGEROUS SITUATION AND A NEAR-ACCIDENT. MANUFACTURER PREVIOUSLY WARNED OF 'IGNITION SWITCH FAILURE', BUT WOULD ONLY REPAIR AFTER FAILURE AND BEFORE 10 YRS OR 100,000 MILES. MY CAR HAS 100,600 MILES. MANUFACTURER REFUSES…