2003 Volvo Xc90 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
5 safety recalls, most serious first
1. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
What could happen: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 XC90.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 06V155000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING:LINKAGES:TIE ROD ASSEMBLY
Summary: ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes: VOLVO RECALL NO. R157. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires.
What could happen: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
The fix: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 XC90.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 10V566000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Summary: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Notes: VOLVO SAFETY RECALL NO. R231. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRON…
What could happen: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The fix: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 XC90.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 09V483000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes: VOLVO SAFETY RECALL NO. R220. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
4. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
What could happen: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
The fix: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 XC90.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 06V144000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
Summary: ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Notes: VOLVO RECALL NO. R156. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATIONVOLVO RECALL NO. R156. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
5. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.
What could happen: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
The fix: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2003 XC90.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 03V391000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:REAR/OTHER
Summary: ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Notes: VOLVO RECALL NO. 127. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2003 Volvo Xc90 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (51), Electrical system (18), Fuel system (10), Engine (9), Suspension (9).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/20/2022 · Fuel system
Fuel line was recalled in 2010. Volvo repaired it now it has the same problem. And is leaking fuel. Same line that they replaced in 2010. Please recall.
02/02/2021 · Transmission / drivetrain
TRANSFER CASE KEEPS LOCKING UP AND MESSING UP. IN PAST YEAR PAID 1500 TWO TIMES TO REPLACE TRANSFER CASE AND IS NOW IN SHOP AGAIN FOR SAME REASON. TRANSFER CASE LOCKING UP. FEB 2020, JULY 2020, AND NOW JANUARY 2021 FEB GOING SPEED OF 35-40, JULY ON HIGHWAY SPEED OF 70 IN MIDDLE OF FREEWAY, AND JAN SPEED OF 35
12/15/2015 · Electrical system
DRIVING THE XC90 AND SUDDENLY THERE IS A HUGE THUMP AND CLICKING FROM THE DASHBOARD. ALL THE DIALS AROUND THE SPEDOMETER STOP WORKING.. IF WE KEEP DRIVING THERE ARE MORE THUMPS AND WE QUICKLY LOSE ENGINE POWER - IT IS EXTREMELY SCARY WHEN IT HAPPENS.. ALL THE LIGHTS COME ON (INSIDE THE CAR), DASHBOARD GOES DEAD ETC ETC. IT IS EXTREMELY DANGEROUS .. IT HA…
08/31/2015 · Transmission / drivetrain
WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YE…
08/19/2015 · Electrical system
VEHICLE DRAINS WATER ON TO FRONT PASSENGER FLOOR, AND OCASSIONAL DRIVER SIDE AFTER IT RAINS. IT IS A KNOW PROBLEM THAT A CLASS ACTION SUIT WAS WON IN NEW JERSEY, INCLUDING 5 OTHER STATES. THE WATER IS FROM CLOGGED DRAIN TUBES IN SUNROOF AND SOMETIMES SHRINKIAGE OF DRAIN TUBE THAT DISLODGES. VEHICLE NOW HAS A MUSTY SMELL FROM THE FREQUENT WATER IN THE VEHICL…
05/11/2015 · Fuel system
TL* THE CONTACT OWNS A 2003 VOLVO XC90. WHILE DRIVING AT APPROXIMATELY 55 MPH, FUEL FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS ALL OVER THE EXHAUST PIPE AND THE BOTTOM OF THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS CRACK AND LEAKING FUEL.…
03/17/2015 · Fuel system
TL* THE CONTACT OWNS A 2003 VOLVO XC90. THE CONTACT STATED THAT FUEL FUMES EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THERE WAS A LEAK IN THE FUEL PUMP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT ASSOCIATED WITH NHTSA CAMPAIG…
01/29/2015 · Transmission / drivetrain
TRANSMISSION FAILED WITHOUT WARNING. HERE'S THE STORY, MY XC90 WAS DEALER SERVICED A WEEK AGO (PM), TOOK ON A SHORT ROAD TRIP OVER WEEKEND, FORTUNATELY MADE IT HOME BEFORE IT BROKE DOWN. WENT TO WORK UPON RETURNING FROM TRIP AND WHILE I WAS PARKING THE TRANSMISSION FAILED TO ENGAGE IN ANY GEAR. VERY UNSAFE! NO WARNING LIGHTS ILLUMINATED AND THERE WAS NO 'LI…